Abstract:Gas-liquid two-phase flows frequently occur in various flow channels in engineering systems with heat and mass transport processes. The channel geometry affects thermo-fluid behavior generally. Extensive research is done on gas-liquid two-phase flows in circular and annular channels with a wealth of local two-phase flow measurement data. Square channels are used in various engineering disciplines, but there has only been limited experimental research on two-phase flows in square channels with local flow parameter measurements. For two-phase flow analyses in square channels, knowledge of the flow characteristics and model validation against some key parameters, such as the drift-flux parameters and the interfacial area concentration, is crucial. An experiment for upward bubbly flows was conducted in a large square channel with an inside cross-section of 0.136 x 0.136 m. A four-sensor optical probe and a hotfilm anemometer were used to measure local two-phase flow parameters at 66 points in an octant symmetric triangular cross-section at three axial locations. The measured two-phase flow parameters were the void fraction, axial gas velocity, axial liquid velocity, interfacial area concentration, and bubble Sauter mean diameter. The flow characteristics through flow development were investigated based on the local measurement data. The local measurement data directly determined the drift-flux parameters through their definitions. The distribution parameters determined through experimentation could be reproduced by the existing correlation for large circular pipes indicating that the flow characteristics in large square channels may be similar to those in large circular pipes. Based on existing drift-flux correlations for large circular pipes, the void fractions in the current experiment could be fairly predicted. Furthermore, the interfacial area concentrations could be predicted by existing correlations with reasonable accuracy. (c) 2023 Elsevier Ltd. All rights reserved.

EXPERIMENTAL STUDIES ON TRANSIENT STRUCTURES OF DENSE GAS-SOLID FLOWS IN A VERTICAL CHANNEL

Experimental Investigation of Flow Development in Large-Scale Bubble Columns in the Churn-Turbulent Regime

Experimental and numerical investigation of solid behavior in a gas–solid turbulent fluidized bed

Flow Regime Transition and Liquid Distribution in a 3D Concurrent Downflow Three-Phase Moving Bed

Experimental Measurement and Theoretical Analysis on Bubble Dynamic Behaviors in a Gas-Liquid Bubble Column

Experimental Investigation on Submerged Gas-Liquid Mixture Injection into Water Through A Micro-Channel

Gas-Liquid Bubbly Turbulent Upward Flow in Square Duct

Multi-dimensional Characteristics of Upward Bubbly Flows in a Vertical Large-Size Square Channel

Experimental investigations of gas–liquid two-phase flow in a horizontal mini pipe: Flow regime, void friction, and frictional pressure drops

Mechanisms for Particle Clustering in Upward Gas-Solid Flows

Experimental Study on Gas-Liquid Flow Characteristics of Submerged Air Jets

On Coherent Structures in Gas–solid Fluidization

Transition from Bubbling to Jetting in Submerged Gas-Liquid Jets Through a Minichannel

Experimental Investigation of the Particle Distribution of Gas-Solid Turbulent Flow in the Boundary Layer

Studies of gas-liquid two-phase flows in horizontal mini tubes using 3D reconstruction and numerical methods

Experimental Investigations of Three-Dimensional Flow Field around the Head of Gas-Liquid Slug Flow in Microchannels

Research on motion characteristics of gas-solid jet flow

Experimental Study on Gas-Liquid Two-Phase Stratified Flow at High Pressure in a Horizontal Pipe

STUDY ON TURBULENCE MODULATION OF GAS-SOLID TWO-PHASE FLOW IN A SUDDEN-EXPANSION TUBE

Dense Gas-Particle Flow in Vertical Channel by Multi-Lattice Trajectory Model

Experimental study of two-phase flow structure in churn-turbulent to annular flows