Abstract:It has been known for a long time that certain additives (e.g., NaCl, CaCl2, Na2CO3, Fe2O3) can increase the sulfur dioxide capture-capacity of limestones. In a recent study we demonstrated that very small amounts of Na2CO3 can be very beneficial for producing sorbents of very high sorption capacities. This paper explores what contributes to these significant increases. Mercury porosimetry measurements of calcined limestone samples reveal a change in the pore-size from 0.04-0.2 microm in untreated samples to 2-10 microm in samples treated with Na2CO3--a pore-size more favorable for penetration of sulfur into the particles. The change in pore-size facilitates reaction with lime grains throughout the whole particle without rapid plugging of pores, avoiding premature change from a fast chemical reaction to a slow solid-state diffusion controlled process, as seen for untreated samples. Calcination in a thermogravimetric reactor showed that Na2CO3 increased the rate of calcination of CaCO3 to CaO, an effect which was slightly larger at 825 degrees C than at 900 degrees C. Peak broadening analysis of powder X-ray diffraction data of the raw, calcined, and sulfated samples revealed an unaffected calcite size (approximately 125-170 nm) but a significant increase in the crystallite size for lime (approximately 60-90 nm to approximately 250-300 nm) and less for anhydrite (approximately 125-150 nm to approximately 225-250 nm). The increase in the crystallite and pore-size of the treated limestones is attributed to an increase in ionic mobility in the crystal lattice due to formation of vacancies in the crystals when Ca is partly replaced by Na.

The Effect of Na2CO3 on Direct Sulfuration of CaCO3 in the Atmosphere of O2/CO2

Modulation of nano CaCO3pore size and effect on properties of carbonation reaction

Study on the kinetics of Ca-based CO2 sorbent of carbonation and calcination for adsorption enhanced reforming process

Calcination–carbonation Durability of Nano CaCO3 Doped with Li2SO4

The Effect of CaO Content on Sorption Performance of Nano CaO Based CO2 Adsorbent

Study on CO2 Absorption-Mineralization Characteristics of Mixed Amine Solution Coupled with CaO and Key Influencing Factors in Mineralization Process

Effect of Sulfated CaO on NO Reduction by NH<sub>3</sub>in the Presence of Excess Oxygen

Effect Of Sulfated Cao On No Reduction By Nh3 In The Presence Of Excess Oxygen

Experimental Study on Preparation of Calcium Oxide by Coal Reduction of Calcium Sulfate in Carbon Dioxide Atmosphere

Understanding the Enhancement Effect of Na2CO3 Additive on the Direct Sulfation of Limestone

Comparison of Characteristics of Calcium-Based Desulfurization in Air and in an Atmosphere of O2/CO2

The Effect of Metallic Salt Additives on Calcium-Based Desulfurization in O_2-CO_2 Pulverized Coal Combustion

Effect of Steam to the CaO Conversion Ratio During the Flue Gas Desulfurization Reaction with CaO Particles

The Study of Calcium Sulfate Decomposition by Experiments Under O2/CO2 Atmosphere

Sulfation Performance of CaO under Circulating Fluidized Bed Combustion-Like Condition

Characterization of the enhancement effect of Na2CO3 on the sulfur capture capacity of limestones

@Experimental Study of the Influence of CaCO3on NH3+NO+O2 Reaction System

Analysis Of Calcium Sulfate Decomposition By Thermodynamics Undero(2)/Co2 Atmosphere

Simulation and calculation on the kinetics of CaO desulfurization catalytic ef fects of alkali salts

Experimental Study of Decomosition Behavior of CaSO4 in Different Atmospheres

Simultaneous Absorption of SO2 and NO from Flue Gas with CaCO3 and Liquid Phase Oxidation