Abstract:Purpose The supercritical design of tail rotor drive shaft has attracted more attention in helicopter design due to its high power–weight ratio and low maintenance cost. However, there exists excessive vibration when the shaft passes through the critical frequency. Dry friction damper is the equipment applied to the drive shaft to suppress the excessive vibration. In order to figure out the damping mechanism of the dry friction damper and improve the damping efficiency, the dynamic model of the shaft/damper system is established based on the Jeffcott rotor model. Design/methodology/approach The typical frequency response of the system is studied through bifurcation diagrams, amplitude-frequency characteristic curves and waterfall frequency response spectrum. The typical transient responses under frequency sweeps are also obtained. Findings The results show that the response of the system changes from periodic no-rub motion to quasi-periodic rub-impact motion, and then to synchronous full annular rub-impact, and finally, back to periodic no-rub motion. The slip of the rub-impact ring improves the stability of the system. Besides, the effects of the system parameters including critical dry friction force, rub-impact friction coefficient, initial clearance on the stability and the vibration damping capacity are studied. It is observed that the stability changes significantly varying the three parameters respectively. The vibration damping capacity is mainly affected by the critical dry friction force and the initial clearance. Originality/value Presented results provide guidance for the design of the dry friction damper.

Modal Frequency and Stability of Rotor System Supported by Viscoelastic Elastomeric Dampers

CHARACTERISTICS OF MODAL DAMPING OF STEEL AND CFRP STAY CABLES WITH OIL DAMPERS

Application of Elastomer O-rings Damper in High Speed Spin Tester

Research On Dynamic Characteristics Of A Magnetorheological Damper With Decoupling Mechanism

Dynamic Characteristics and Modeling of A New Magnetorheological Damper for Broadband Vibration Control

A Disk-Type Magneto-Rheological Fluid Damper for Rotor System Vibration Control

Active Vibration Control of Rotor System by A Magneto-Rheological Fluid Damper

A Disc-Type Magneto-Rheologtic Fluid Damper

Dynamics of A Rotor Supported on Magnet-Rheological Fluid Squeeze Film Damper

Stability and modal analysis of an unbalanced asymmetric multi-disk rotor system on bearings as viscoelastic substrate

Mechanical model and structural control performance of a new rotation-magnified viscoelastic damper

Vibration Analysis of a Nonlinear Rotor-Bearing-seal System

Numerical Method for Computing Modal Damping of Rotor System

Dynamic Models of Flexible Rotors Supported on an MR Fluid Damper (i):Cantilever Rotor with One Disk

Nonlinear vibration response of a helicopter supercritical tail rotor drive shaft equipped with a dry friction damper

Influence of width of squeeze film damper on the transient response of rotor systems

A modeling method for a rotor system with an active floating ring squeeze film damper

Nonlinear dynamic of flexible rotor supported by turbulent bearings with quadratic damping and temperature dependent viscosity

Dynamic Characteristics Analysis of Flexible Rotor System With Pedestal Looseness

Dynamic Behavior Analysis of Intermediate Bearing-Squeeze Film Dampers-Rotor System under Constant Maneuvering Overload

Nonlinear dynamics of asymmetrically supported supercritical rotor equipped with a dry friction damper