Abstract:When the rotor rotates at a constant speed, the transverse crack opens and closes alternatively, due to gravity, and thus a “breathing effect” occurs. This variance in shaft stiffness is time-periodic, and hence a parametrically excited system is expected. The parametric excitation from the time-varying stiffness causes instability and severe vibration under certain operating conditions. Current research mostly focused on the rotor with single transverse crack. There are few studies on the multi-cracked rotor system. In fact, the interaction between the multiple parametric excitations with various phasing and amplitude, which are induced by the multiple breathing transverse cracks, would make the instability behavior of the system differ distinctly from that of the single cracked rotor system. Moreover, how the instability regions change with various crack breathing mechanisms should also be investigated. Thus, the parametric instability of a rotor-bearing system with two breathing transverse cracks is studied in the paper. First, the finite element equations of motion are established for the cracked rotor system. Two types of crack breathing mechanisms, of which one is more accurate (new) and the other is empirical (old), are adopted in the finite element formulation. Then, a generalized Bolotin's method is introduced for determining the boundaries of the primary and secondary instability regions. Based upon these, instability analysis for a practical used rotor-bearing system with single and two cracks are conducted, respectively. The instability regions induced by the single transverse crack with new and old breathing mechanisms are compared with each other. For the two-cracked rotor system, the variations of the unstable boundaries with crack depths, orientation angles and positions are observed and discussed in detail. It is shown from the results that the dynamic instability of the two-cracked rotor-bearing system indeed have some unique features that differ from that of the single cracked rotor system.

Intermittent chaos and bifurcation in time domain of the response of cracked rotors

Stiffness and dynamical behavior of Jeffcottrotor with cross crack

Dynamics Behavior of Multi-Disk Flexible Rotor System with Transverse Crack

Study on Fatigue Degradation Behavior of a Cracked Rotor Subjected to Lateral Vibration

Research on Vibration Response of a Multi-Faulted Rotor System Using LMD-based Time-Frequency Representation

BIFURCATION AND CHAOS IN A RUB-IMPACT JEFFCOTT ROTOR SYSTEM

The dynamic behavior of a rotor system with a slant crack on the shaft

The Dynamics of a Cracked Rotor with an Active Magnetic Bearing

Parametric Instability of a Jeffcott Rotor with Rotationally Asymmetric Inertia and Transverse Crack

Bifurcation and Chaos in a Dynamical System of Rub-Impact Rotor

Effects of Active Magnetic Bearing Controller on Fault Characteristics of Jeffcott Cracked Rotor

Dynamic Characteristics of Rotor System with a Slant Crack Based on Fractional Damping

Stability And Dynamics Of A Rotor System With A Slant Crack On The Shaft

Parametric Instability of a Rotor-Bearing System with Two Breathing Transverse Cracks

Nonparametric Modeling and Vibration Analysis of Uncertain Jeffcott Rotor with Disc Offset

Bifurcation Behavior of a Flexible Rotor Supported on Nonlinear Squeeze Film Dampers Without Centralized Springs

Dynamic analysis of slant cracked rotor system considering nonlinear oil film force

The nonlinear dynamics analysis of stochastic delay Jeffcott rotor-seal system with the elastic support

DYNAMIC ANALYSIS OF A JEFFCOTT ROTOR SYSTEM WITH AN OPENING SLANT CRACK ON ITS SHAFT

Dynamic Response of Cracked Rotor-Bearing System under Time-Dependent Base Movements

The influence of cracks in rotating shafts