Abstract:Crystallization characteristics of the CaO-SiO2-B2O3-TiO2 glass have been studied using scanning electron microscopy, X-ray diffraction and differential thermal analysis techniques. The crystallization kinetic parameters of this glass were estimated under non-isothermal conditions using the Matusuta-Sakka equation. Glass with fine particles (<74 μm), case referred to as ‘‘site saturation’’, was used to obtain the non-isothermal differential thermal analysis curves. Bulk glass-ceramics with dense and nonporous morphology are obtained after the heating treatment indicating the strong heterogeneous nucleation at the junction of gain boundaries in the case of “site saturation”. As the content of TiO2 exceeds 18%, the predominant crystal phase changes from CaSiO3 to CaTiSiO5, until CaTiSiO5 becomes the only crystal phase of the glass at 26% TiO2. The crystallization activation energies, E G, are in the range of 245–514 kJ/mol. As TiO2 increases from 10% to 18%, crystallization ability of the glass decreases gradually and the crystallization corresponds to one-dimensional growth mechanism or surface crystallization, while as TiO2 further increases from 18% to 26%, not only does the glass show an increasing crystallization ability, but also the crystal growth changes to the two-dimensional growth mechanism. Within the range of 22%–26%, TiO2 plays the role of strengthening the crystallization of the glass by acting as a major component in the glass to form Ti-bearing compound. From the standpoint of glass-ceramics preparation, the glass containing more TiO2 (such as 26%) with CaTiSiO5 as the only crystal phase is favorable in the present study.

Studies on the crystallization dynamics o Ca-P-Si glass-ceramic

Crystallization Kinetics of MgO–Al2O3–SiO2 Glass-Ceramics

Influence of different TiO2 content on crystallization of CaO–MgO–P2O5–SiO2 system glasses

Study on isothermal crystallization kinetics of mica glass ceramics

Effect of Changing TiO2 Content on Structure and Crystallization of CaO-Al2O3-SiO3 System Glasses

Crystallization of aluminosilicate glass with additive TiO2

Effect of ZrO2 on crystallization of CaO–P2O5–SiO2 glasses

Crystallization kinetics and dielectric properties of barium strontium titanate based glass–ceramics

Effect of TiO2 on the crystallization of mica glass-ceramics

Crystallization Kinetics and Mechanism of Low-Dielectric, Low-Temperature, Cofirable CaO-B<sub>2</sub>O<sub>3</sub>-SiO<sub>2</sub>Glass-Ceramics

Differential thermal analysis on the crystallization kinetics of K2O-B2O3-MgO-Al2O3-SiO2-TiO2-F glass

Crystallization and Thermal Expansion of MgO-Al<sub>2</sub>O<sub>3</sub>-SiO<sub>2</sub>-TiO<sub>2</sub> Glass-Ceramics

Changes of the Mechanical Properties during Crystallization of CaO-P2O5-SiO2-MgO-F- Glass Ceramics

Insight into the structure and crystallization of SiO2-Al2O3-P2O5-Na2O-MgO-CaO glass system with Mg-Ca substitution: A molecular dynamics study

Non-isothermal crystallization kinetics of CaO-SiO2-B2O3-TiO2 glass studied by differential thermal analysis in the case of “site saturation”

Crystallization and Thermal Expansion of MgO-Al<sub>2</sub>O<sub>3</sub>-SiO<sub>2</sub>-TiO<sub>2</sub> Glass-Ceramics

Effect of Crystallization of Cao-P2o5-Sio2-Mgo-F- Glass-Ceramics on Its Mechanical Properties

Crystallization behavior of MgO-Al2O3-SiO 2-P2O5 glass-ceramics

Influence of nucleating agents on crystallization and electrical properties of SiO2–MgO–MgF2–K2O mica glass-ceramics

Effects of Cr2O3 additive on crystallization behavior of MgO-Al2O3-SiO2-TiO2 glass-ceramics

Studies on the crystallization dynamics o Ca-P-Si glass-ceramic

Crystallization Kinetics of MgO–Al2O3–SiO2 Glass-Ceramics

Influence of different TiO2 content on crystallization of CaO–MgO–P2O5–SiO2 system glasses

Study on isothermal crystallization kinetics of mica glass ceramics

Effect of Changing TiO2 Content on Structure and Crystallization of CaO-Al2O3-SiO3 System Glasses

Crystallization of aluminosilicate glass with additive TiO2

Effect of ZrO2 on crystallization of CaO–P2O5–SiO2 glasses

Crystallization kinetics and dielectric properties of barium strontium titanate based glass–ceramics

Effect of TiO2 on the crystallization of mica glass-ceramics

Crystallization Kinetics and Mechanism of Low-Dielectric, Low-Temperature, Cofirable CaO-B<sub>2</sub>O<sub>3</sub>-SiO<sub>2</sub>Glass-Ceramics

Differential thermal analysis on the crystallization kinetics of K2O-B2O3-MgO-Al2O3-SiO2-TiO2-F glass

Crystallization and Thermal Expansion of MgO-Al<sub>2</sub>O<sub>3</sub>-SiO<sub>2</sub>-TiO<sub>2</sub> Glass-Ceramics

Changes of the Mechanical Properties during Crystallization of CaO-P2O5-SiO2-MgO-F- Glass Ceramics

Insight into the structure and crystallization of SiO2-Al2O3-P2O5-Na2O-MgO-CaO glass system with Mg-Ca substitution: A molecular dynamics study

Non-isothermal crystallization kinetics of CaO-SiO2-B2O3-TiO2 glass studied by differential thermal analysis in the case of “site saturation”

Crystallization and Thermal Expansion of MgO-Al&lt;sub&gt;2&lt;/sub&gt;O&lt;sub&gt;3&lt;/sub&gt;-SiO&lt;sub&gt;2&lt;/sub&gt;-TiO&lt;sub&gt;2&lt;/sub&gt; Glass-Ceramics

Effect of Crystallization of Cao-P2o5-Sio2-Mgo-F- Glass-Ceramics on Its Mechanical Properties

Crystallization behavior of MgO-Al2O3-SiO 2-P2O5 glass-ceramics

Influence of nucleating agents on crystallization and electrical properties of SiO2–MgO–MgF2–K2O mica glass-ceramics

Effects of Cr2O3 additive on crystallization behavior of MgO-Al2O3-SiO2-TiO2 glass-ceramics

Crystallization and Thermal Expansion of MgO-Al<sub>2</sub>O<sub>3</sub>-SiO<sub>2</sub>-TiO<sub>2</sub> Glass-Ceramics