Abstract:In comparison with conventional air combustion, char particle reacts with higher concentrations of O-2 and CO2 in the oxy-fuel combustion. At higher temperatures, strong Stefan flow is formed at the char surface and the CO gas-reaction occurs in the boundary layer, which have significant effects on the char reaction and the mass transfer. But Stefan flow and CO gas-phase reaction are often neglected in the study of conventional coal combustion. In this work, with the consideration of CO oxidation and Stefan flow in the boundary layer of a char particle, modifications to the mass transfer coefficients were presented for the coal oxy-fuel combustion. Better improvement was achieved in predicting the mass transfer coefficient by comparing with the experimental data. Further analyses indicated that the mass transfer coefficient of O-2 decreases and that of CO2, increases in the presence of CO gas-phase reaction. Moreover, the closer the CO flame sheet is to the char surface, the smaller the correction factor of O-2 mass transfer coefficient and the larger the correction factor of CO2. If only considering the oxidation reaction at the particle's surface, the minimum correction factor of O-2 is 0.5 which is 32.5% lower than that in the absence of CO gas-phase reaction. If only the surface gasification reaction is considered, the correction factor for CO2 will increase rapidly at the flame location of about ten times the particle radius, and reach 1.0 at three times the particle radius which means that it is unnecessary to correct the diffusion coefficient. This is very different from the case neglecting the boundary layer reaction. If the surface oxidation and surface gasification are considered simultaneously, the increase of the number of surface reaction will decrease the mass transfer coefficients for both O-2 and CO2, and will have greater influence on CO2 transfer than on O-2. These changes of reactive gas mass transfer indicate the significant impacts of CO homogeneous reaction in the oxy-fuel combustion of coal char. (C) 2014 Elsevier Ltd. All rights reserved.

Experimental Study of Oxygen Mass-transfer Coefficient in a Surface Ash Layer During the Burning of Pulverized Coal

Measurements and Modelling of Oxy-Fuel Coal Combustion

OXYGEN-ENRICHED COMBUSTION IN A HORIZONTAL FURNACE AND THREE- DIMENTIONAL NUMERICAL SIMULATION TEST THEREOF

Study on the Anisotropy of Mass Transfer for Oxygen in the Ash Layer of Shale Char Particles

Experimental Study on Combustion Behaviors and Carbon Monoxide Emission Characteristics of Single Coal Pellets

TEST STUDY ON AND ANALYSIS OF BURNING BEHAVIOR FOR COAL UNDER ATMOPHERE OF O2/CO2

Mass Transfer Coefficients Considering Boundary Layer Reaction in Oxy-Fuel Combustion of Coal Char

Correction to Mass Transfer Coefficients Considering Volumetric Reaction in Boundary Layer of a Char Particle in O_2/CO_2

Experimental Study on the Porous Structure of Variously Sized Fly Ash Particles under Different Combustion Conditions

The Research on Gas Diffusion Through the Coal Ash Layer During the Coal Combustion Process

Study of the Characteristics of Coal Coke under the Condition of Oxygen-enriched Combustion

Mass Transfer Coefficients Considering Effects of Steam in Oxy-Fuel Combustion of Coal Char

Experimental and theoretical analyses on ignition and surface temperature of dispersed coal particles in O2/N2 and O2/CO2 ambients

Experimental and Modeling Investigation of Oxy-Coal Combustion Based on Langmuir-Hinshelwood Kinetics and Direct Calculation of Char Morphology

Experimental and Kinetics Studies on the Evolution and Effects of Ash Film During Pulverized Coal Char Combustion

Experimental Study of the Flame Propagation Characteristics of Pulverized Coal in an O2/CO2 Atmosphere

Experimental investigation on ash deposition of a bituminous coal during oxy-fuel combustion in a bench-scale fluidized bed

Experimental research on coal/char combustion in O-2/CO2 mixed atmosphere

Thermal Analysis Kinetics Study of Pulverized Coal Combustion under Oxygen-Rich Atmosphere

Comparison of pulverized coal combustion in air and in O2/CO2 mixtures by thermo-gravimetric analysis

Correction to Mass Transfer Coefficients for the Combustion of a Char Particle in O2/CO2/H2O Atmosphere