Abstract:With types of in-house-synthesized multi-walled carbon nanotubes (CNTs) and the nitrates of the corresponding metallic components, highly active CNT-promoted Cu–ZnO–Al 2 O 3 catalysts, symbolized as Cu i Zn j Al k - x %CNTs, were prepared by the co-precipitation method. Their catalytic performance for methanol synthesis from H 2 /CO/CO 2 was studied and compared with the corresponding CNT-free co-precipitated catalyst, Cu i Zn j Al k . It was shown experimentally that appropriate incorporation of a minor amount of the CNTs into the Cu i Zn j Al k could significantly increase the catalyst activity for methanol synthesis. Under the reaction conditions of 493 K, 5.0 MPa, H 2/ CO/CO 2 /N 2 = 62/30/5/3 (v/v), GHSV = 8000 h -1 , the observed CO conversion and methanol formation rate over a co-precipitated catalyst of Cu 6 Zn 3 Al 1 -12.5%CNTs reached 36.8% and 0.291 μmol CH 3 OH s -1 (m 2 -surf. Cu) -1 , which was about 44 and 25% higher than those (25.5% and 0.233 μmol CH 3 OH s -1 (m 2 -surf. Cu) -1 ) over the corresponding CNT-free co-precipitated catalyst, Cu 6 Zn 3 Al 1 . Addition of a minor amount (10–15 wt%) of the CNTs to the Cu 6 Zn 3 Al 1 catalyst was found to considerably increase specific surface area, especially Cu surface area of the catalyst. H 2 -TPD measurements revealed that the CNTs and the pre-reduced CNT-promoted catalyst systems could reversibly adsorb and store a considerably greater amount of hydrogen under atmospheric pressure at temperatures ranging from room temperature to ∼573 K. This unique feature would be beneficial for generating microenvironments with higher stationary-state concentration of active hydrogen adspecies on the surface of the functioning catalyst, especially at the interphasial active sites since the highly conductive CNTs might promote hydrogen spillover from the Cu sites to the Cu/Zn interphasial active sites, and thus be favorable for increasing the rate of the CO hydrogenation reactions. Alternatively, the operation temperature for methanol synthesis over the CNT-promoted catalysts can be 15–20 degrees lower than that over the corresponding CNT-free contrast system. This would contribute considerably to an increase in equilibrium CO conversion and CH 3 OH yield. The results of the present work indicated that the CNTs could serve as an excellent promoter.

New Rh-Zno/Carbon Nanotubes Catalyst For Methanol Synthesis

Study on Rh-ZnO/MWNTs Catalyst for Methanol Synthesis

Highly Active CNT-Promoted Cu–ZnO–Al2O3 Catalyst for Methanol Synthesis from H2/CO/CO2

Highly Active CNT-Promoted Cu–ZnO–Al 2 O 3 Catalyst for Methanol Synthesis from H 2 /CO/CO 2

Highly Active CNT-Promoted Cu–ZnO–Al<sub>2</sub>O<sub>3</sub> Catalyst for Methanol Synthesis from H<sub>2</sub>/CO/CO<sub>2</sub>

Methanol synthesis from H2/CO/CO2 over CNTs-promoted Cu-ZnO-Al2O3 catalyst

Carbon dioxide hydrogenation to methanol over Cu/ZrO2/CNTs: effect of carbon surface chemistry

Highly Active CNTs-Promoted Cu-based Catalyst Forhydrogenation of CO/CO2 to CH3OH

Long Carbon Nanotubes Intercrossed Cu/Zn/Al/Zr Catalyst for CO/CO2 Hydrogenation to Methanol/dimethyl Ether

Study of Highly Active Cu-based Catalyst Promoted by Nickel-Modified Multi-Walled Carbon Nanotubes for Methanol Synthesis

MOF-derived N-doped Carbon Coated CoP/carbon Nanotube Pt-based Catalyst for Efficient Methanol Oxidation

Carbon Nanotube-Supported Pd–ZnO Catalyst for Hydrogenation of CO2 to Methanol

RuO2·xH2O Supported on Carbon Nanotubes as a Highly Active Catalyst for Methanol Oxidation

Optimizing Hydrogen Production with a Zinc Ferrocyanide–Carbon Nanotube Catalyst

Engineering nanoscale H supply chain to accelerate methanol synthesis on ZnZrOx

Study on Highly Active Catalysts and a Once—Through Process for Methanol Synthesis from Syngas

Highly effective hydrogen production from steam reforming of methanol over CNTs-promoted Cu/ZnO/Al2O3 catalysts

CO hydrogenation on Rh-based catalysts for ethanol production

High Performance PtRuIr Catalysts Supported on Carbon Nanotubes for the Anodic Oxidation of Methanol.

Cu-supported nano-ZrZnOx as a highly active inverse catalyst for low temperature methanol synthesis from CO2 hydrogenation

A Novel Co-decorated CNT-promoted CuO-ZnO-ZrO2 Catalyst for CO2 Hydrogenation to Methanol