Abstract:Background: A considerable challenge in the development of bioprocesses for producing chemicals and fuels has been the high cost of feedstocks relative to oil prices, making it difficult for these processes to compete with their conventional petrochemical counterparts. Hence, in the absence of high oil prices in the near future, there has been a shift in the industry to produce higher value compounds such as fragrances for cosmetics. Yet, there is still a need to address climate change and develop biotechnological approaches for producing large market, lower value chemicals and fuels. Results: In this work, we study ethylene glycol (EG), a novel feedstock that we believe has promise to address this challenge. We engineer Escherichia coli (E. coli) to consume EG and examine glycolate production as a case study for chemical production. Using a combination of modeling and experimental studies, we identify oxygen concentration as an important metabolic valve in the assimilation and use of EG as a substrate. Two oxygen-based strategies are thus developed and tested in fed-batch bioreactors. Ultimately, the best glycolate production strategy employed a target respiratory quotient leading to the highest observed fermentation performance. With this strategy, a glycolate titer of 10.4 g/L was reached after 112 h of production time in a fed-batch bioreactor. Correspondingly, a yield of 0.8 g/g from EG and productivity of 0.1 g/L h were measured during the production stage. Our modeling and experimental results clearly suggest that oxygen concentration is an important factor in the assimilation and use of EG as a substrate. Finally, our use of metabolic modeling also sheds light on the intracellular distribution through central metabolism, implicating flux to 2-phosphoglycerate as the primary route for EG assimilation. Conclusion: Overall, our work suggests that EG could provide a renewable starting material for commercial biosynthesis of fuels and chemicals that may achieve economic parity with petrochemical feedstocks while sequestering carbon dioxide.

The Development of Continuous Production Process of Ethylene Glycol Monophenyl Ether

Modeling and Analysis of New Reactor Concepts for Poly(ethylene Terephthalate) Esterification Process

A new technology of synthesis and separation of glycine

Improvement on Synthesis and Purification Process of Neopentyl Glycol

Investigation of a Dynamic Operation Mode of Ethylene Polymerization Process with a Liquid-Containing Fluidized Bed

Ethylene Glycol Purification by Melt Crystallization: Removal of Short-Chain Glycol Impurities

Stability Analysis Of Ethylene Polymerization In A Liquid-Containing Gas-Solid Fluidized Bed Reactor

[Application of Continuous Mixing Technology in Ethanol Precipitation Process of Salvia Miltiorrhiza by Using Micromixer].

Preparation of Ethylene Glycol Monoethyl Ether Acetate Using a Tubular Reactor

Selective production of ethylene glycol at high rate via cascade catalysis

Highly selective synthesis of propylene glycol ether from methanol and propylene oxide catalyzed by basic ionic liquid

Ethanol-water Separation in Hollow Fiber Membrane Contactor

Ethylene Glycol Purification by Melt Crystallization:Removal of 2-Methoxyethanol Impurity

Plant-Wide Modeling and Economic Analysis of Monoethylene Glycol Production

Efficient synthesis of glycerol carbonate over a commercially available 4A molecular sieve via an integrated vacuum reactive distillation process

Ethylene glycol co-solvent enhances alkyl levulinate production from concentrated feeds of sugars in monohydric alcohols

One-step continuous/semi-continuous whole-cell catalysis production of glycolic acid by a combining bioprocess with in-situ cell recycling and electrodialysis

Direct Esterification in Helical Continuous-Flow Microreactors under an Aqueous Environment: Optimization, Reaction Kinetics, and Process Intensification

Green Synthesis of Biobased Glycerol Levulinate Ketal in a Continuous Flow Reactor: Optimization, Kinetics and Simulation

Continuous Acetone-Butanol-Ethanol (ABE) fermentation with in situ solvent recovery by silicalite-1 filled PDMS/PAN composite membrane

Engineering Escherichia coli for the utilization of ethylene glycol