Abstract:Weakly-agglomerated nanocrystalline (ZrO2)(1-x)(Sc2O3)(x) ( x = 0.02 - 0.16) powders with high surface area (106 - 186 m(2) g(-1)) and uniform particle size (5.7 - 9.5 nm) were synthesized by a two-step hydrothermal process in the presence of urea, and their complex phase evolution upon calcinations over 400 - 1400 degreesC were studied by a combined utilization of X-ray diffraction, in situ high temperature X-ray diffraction, near infrared Fourier transform Raman and ultraviolet Raman spectroscopies. It was discovered that the growth of the grains comprised two stages, and the apparent activation energies, E-a1 (<800 degrees C) and E-a2 (>800 degreesC), are in the range of 5.5 - 12 kJ mol(-1) and 80 - 140 kJ mol(-1), respectively. The crystallite size, microstrain, surface area and growth activation energy of the samples showed a strong dependence on the Sc3+ doping concentration. The nanocrystalline (ZrO2)(1-x)(Sc2O3)(x) samples underwent complex phase transitions upon calcination from 800 to 1000 degreesC. Tetragonal and cubic phases have been preserved when the samples calcined below 800 degreesC as a result of crystallite size and doping effects. At elevated calcination temperature of 1000 degreesC, the compositions at x = 0.04, 0.10 and 0.14 seemed to be in the metastable phase boundaries of m + t, t + beta (Sc2Zr7O17) and beta+gamma (Sc2Zr5O13), respectively. As calcined at 1400 degreesC, the grain size was in the micrometre regime, and t --> m, c --> t", c --> beta and c --> gamma phase transitions occurred on the cooling stage for x less than or equal to 0.04, x = 0.08, 0.10 less than or equal to x less than or equal to 0.12 and x greater than or equal to 0.14, respectively, resulting in the existence of m, t, t", beta and gamma phases in turn at room temperature. Moreover, it was found that the tetragonal phase has been enriched at the surface region for the as-calcined (ZrO2)(0.94)(Sc2O3)(0.06) and (ZrO2)(0.92)(Sc2O3)(0.08) samples.

Preparation of Y2o3 Stabilised Zro2 Ceramic Nanopowders by Surface Doping

Formation and Rate Processes of Y2o3 Stabilized Zro2 Thin Films from Zr(Dpm)(4) and Y(Dpm)(3) by Cold-Wall Aerosol-Assisted Mocvd

Fabrication and Characterization of Y2O3 Stabilized ZrO2 Films Deposited with Aerosol-Assisted MOCVD

Formation and Rate Processes of Y[sub 2]o[sub 3] Stabilized ZrO[sub 2] Thin Films from Zr(DPM)[sub 4] and Y(DPM)[sub 3] by Cold-Wall Aerosol-Assisted MOCVD

Ball milling assisted preparation of nano La–Y/ZrO2 powder ternary oxide system: Influence of doping amounts

Hydrothermal Synthesis of Nanocrystalline ZrO2-8Y2O3-xLn2O3 Powders (Ln = La, Gd, Nd, Sm): Crystalline Structure, Thermal and Dielectric Properties

Synthesis and Characterization of Doped Nano-Sized Ceria–zirconia Solid Solutions

Few-monolayer yttria-doped zirconia films: Segregation and phase stabilization

Doping and Grain Size Effects in Nanocrystalline ZrO2–Sc2O3system with Complex Phase Transitions: XRD and Raman Studies

Preparation of nano-sized 6MgO–2Y2O3–ZrO2 powders by a combined co-precipitation and high energy ball milling process

Preparations and Characterizations of New Mesoporous ZrO2 and Y2O3-stabilized ZrO2 Spherical Powders

Influence of Y2O3 Doping on Phase Evolution and Dielectric Characteristics of ZrO2 Ceramics

Preparation and properties of yttria-stabilized tetragonal phase zirconia nano-ceramics by high gravity

Preparation and Properties of Al<sub>2</sub>O<sub>3</sub> Particle Dispersed 3Y-TZP Nanoceramics Doped with TiO<sub>2</sub>

Co-Doping Effects of Y3+ and Sc3+ on the Crystal Structures, Nanoparticle Properties and Electrical Behavior of Zro2 Solid Solutions Prepared by A Mild Urea-Based Hydrothermal Method

Preparation and Properties of Al<sub>2</sub>O<sub>3</sub> Particle Dispersed 3Y-TZP Nanoceramics Doped with TiO<sub>2</sub>

Doping Effects of Yb3+ on the Crystal Structures, Nanoparticle Properties and Electrical Behaviors of ZrO2 Derived from a Facile Urea-Based Hydrothermal Route

Synthesis of yttria-stabilized zirconia powders for plasma spray by internal gelation

Preparation and properties of Al2O3 particle dispersed 3Y-TZP nanoceramics doped with TiO2

Co-precipitation of nano Mg–Y/ZrO2 ternary oxide eutectic system: Effects of calcination temperature

Improving the Mechanical Properties and Microstructure of 12 mol% Ceria-Stabilized Tetragonal Zirconia Polycrystal Ceramics with Low-Content Nd2O3

Preparation of Y2o3 Stabilised Zro2 Ceramic Nanopowders by Surface Doping

Formation and Rate Processes of Y2o3 Stabilized Zro2 Thin Films from Zr(Dpm)(4) and Y(Dpm)(3) by Cold-Wall Aerosol-Assisted Mocvd

Fabrication and Characterization of Y2O3 Stabilized ZrO2 Films Deposited with Aerosol-Assisted MOCVD

Formation and Rate Processes of Y[sub 2]o[sub 3] Stabilized ZrO[sub 2] Thin Films from Zr(DPM)[sub 4] and Y(DPM)[sub 3] by Cold-Wall Aerosol-Assisted MOCVD

Ball milling assisted preparation of nano La–Y/ZrO2 powder ternary oxide system: Influence of doping amounts

Hydrothermal Synthesis of Nanocrystalline ZrO2-8Y2O3-xLn2O3 Powders (Ln = La, Gd, Nd, Sm): Crystalline Structure, Thermal and Dielectric Properties

Synthesis and Characterization of Doped Nano-Sized Ceria–zirconia Solid Solutions

Few-monolayer yttria-doped zirconia films: Segregation and phase stabilization

Doping and Grain Size Effects in Nanocrystalline ZrO2–Sc2O3system with Complex Phase Transitions: XRD and Raman Studies

Preparation of nano-sized 6MgO–2Y2O3–ZrO2 powders by a combined co-precipitation and high energy ball milling process

Preparations and Characterizations of New Mesoporous ZrO2 and Y2O3-stabilized ZrO2 Spherical Powders

Influence of Y2O3 Doping on Phase Evolution and Dielectric Characteristics of ZrO2 Ceramics

Preparation and properties of yttria-stabilized tetragonal phase zirconia nano-ceramics by high gravity

Preparation and Properties of Al&lt;sub&gt;2&lt;/sub&gt;O&lt;sub&gt;3&lt;/sub&gt; Particle Dispersed 3Y-TZP Nanoceramics Doped with TiO&lt;sub&gt;2&lt;/sub&gt;

Co-Doping Effects of Y3+ and Sc3+ on the Crystal Structures, Nanoparticle Properties and Electrical Behavior of Zro2 Solid Solutions Prepared by A Mild Urea-Based Hydrothermal Method

Preparation and Properties of Al<sub>2</sub>O<sub>3</sub> Particle Dispersed 3Y-TZP Nanoceramics Doped with TiO<sub>2</sub>

Doping Effects of Yb3+ on the Crystal Structures, Nanoparticle Properties and Electrical Behaviors of ZrO2 Derived from a Facile Urea-Based Hydrothermal Route

Synthesis of yttria-stabilized zirconia powders for plasma spray by internal gelation

Preparation and properties of Al2O3 particle dispersed 3Y-TZP nanoceramics doped with TiO2

Co-precipitation of nano Mg–Y/ZrO2 ternary oxide eutectic system: Effects of calcination temperature

Improving the Mechanical Properties and Microstructure of 12 mol% Ceria-Stabilized Tetragonal Zirconia Polycrystal Ceramics with Low-Content Nd2O3

Preparation and Properties of Al<sub>2</sub>O<sub>3</sub> Particle Dispersed 3Y-TZP Nanoceramics Doped with TiO<sub>2</sub>