Studies on Enzyme-Catalyzed Reaction in Supercritical Carbon Dioxide

CHEN Huiqing,YANG Jichu

DOI: https://doi.org/10.3321/j.issn:1000-0054.1999.06.009

1999-01-01

Abstract:This paper studies t he lipase catalyzed esterification of lauric acid and n butanol in supercritic al carbon dioxide. The method is the same as described in “Journal of Tsinghua Un iversity” (Qinghua Daxeu Xuebao), vol.39, No.6, pp31￣34, 1999, by CHEN Huiqing, YANG Jichu. The effect of pressure, temperature, water content of the enzym e, concentration and type of the substrates on the reaction are evaluated. Incre asing the pressure will make the hydration extend of the enzyme decrease, along with the decrease of the activity. However, the solubility of all substrates inc rease when turning the pressure from 8MPa to 20MPa, a higher reactio n rate thus is induced. In the range of 34℃￣60℃, increase of the t emperature will cause a tendency of higher reaction rate. The water contents of the enzyme h ave a great impact on the reaction. The activity of the enzyme reaches its peak at the water mass fraction of 40%. If the concentration of n butanol is greater than 100mmol/L, an obivous inhibition on the enzyme is observed. During e a ch experiment, lauric acid did not inhibit the reaction. The initial ra te increases with the extending of carbon chain in alcohol molecule. When the nu mber of carbon atom is more than 4, the reaction rate lowers down.