Abstract:<p>In order to study the characteristics of 3D gas-liquid interfaces, flow pattern transitions, and void fraction in mini tubes, virtual multi-vision experiments and numerical simulations are conducted in a 5.16 mm horizontal tube with air as the dispersed phase and water as the continuous phase. Air and water flow velocities range from 0.024 to 12.330 m/s and from 0.039 to 0.942 m/s, respectively. A simple setup is adopted to capture images synchronously from two orthogonal views with a prism. 3D gas-liquid interfaces of bubbly, slug, and annular flows in horizontal mini tubes are reconstructed in Matlab based on the captured images. Flow pattern transitions and void fractions with 3D interfaces are comprehensively investigated both experimentally and numerically. The numerical results fit well with experimental data in terms of 3D interfaces, cross-sectional and volumetric void fractions. The results show that three flow patterns (bubbly, slug, and annular) are observed experimentally and numerically. The increases in both bubble size and interfacial fluctuation are the main reasons for flow pattern transitions. Two peaks are observed in the Probability Density Functions figures for intermittent flows, while only one peak is obtained for annular flow. The volumetric void fraction fits well with the homogenous model when the gas quality is lower than 0.8, while the slip ratio is around 1. The velocity difference between the two phases increases dramatically at a higher gas quality, leading to a lower void fraction than the predicted value by the homogenous model. The results agree well with empirical correlations with a mean average deviation about 10%, which validates the experimental and numerical methods in the present work.</p>

Experimental Study on Gas-Liquid Two-Phase Slug Flow--Falling Liquid Film

Online Parameters Measurement of Taylor Flow in Small Channels Using Optical Technique

Experimental Study on Gas-Liquid Flow Characteristics of Submerged Air Jets

Characteristics of Gas-Liquid Slug Flow in Microchannel by Instantaneous Liquid Film Thickness Measurement

Experimental Investigation on Submerged Gas-Liquid Mixture Injection into Water Through A Micro-Channel

Flow Pattern Change in a Vertical Tube for the Liquid Film Suction

Slug Formation Analysis of Liquid–Liquid Two-Phase Flow in T-Junction Microchannels

Experimental investigations of gas–liquid two-phase flow in a horizontal mini pipe: Flow regime, void friction, and frictional pressure drops

Experimental study of Taylor bubble flow in non-Newtonian liquid in a rectangular microchannel

Slug Flow Hydrodynamics Modeling for Gas–Liquid Two-Phase Flow in a Pipe

Submerged Injection of Gas into a Thin Liquid Sheet

An experimental and simulation study on the velocity distribution of the falling film on a horizontal tube in jet mode

Experimental characterization of the dispersed bubbles in the slug of an air–water slug flow in a vertical pipe

Study on effect of gas-liquid two phase physical feature on slug flow in microchannels

Studies of gas-liquid two-phase flows in horizontal mini tubes using 3D reconstruction and numerical methods

Experimental Investigations of Three-Dimensional Flow Field around the Head of Gas-Liquid Slug Flow in Microchannels

Phase Distribution of Gas–Liquid Slug–Annular Flow in Horizontal Parallel Micro-Channels

3D gas-liquid interfaces and flow characteristics of two-phase flows in horizontal tubes

Hydrodynamics and Scaling Laws of Gas–Liquid Taylor Flow in Viscous Liquids in a Microchannel

Study of the Pressure Drop of Liquid–Liquid Slug Flow in a Circular Microchannel

Experimental Study of Low Liquid Loading Gas-Liquid Flow in Near-Horizontal Pipes