Abstract:The capture and sequestration of CO2 generated from large-scale stationary power plants is considered to be one of the leading technologies that could potentially have a significant impact on reducing greenhouse emissions. Among these emerging technologies, the oxy-fuel combustion is a near-zero emission technology that can be adapted to both new and existing pulverized coal-fired power stations. The goal of this work is to make a comparative study on char structural characteristics (including char yield, swelling ratio, BET surface area, pore distribution, morphology) and reactivity during conventional air and oxy-fuel combustion. Specific experimental designs include two series. One is carried out in pure N-2 and CO2 (pyrolysis experiments), and another is prepared in N-2+5%O-2 and CO2+5%O-2. Coal samples included raw coal, low density fraction coal and medium density fraction coal in all experiments. The present study is a further effort to extend our knowledge about physical and chemical structural characteristics and reactivity of char in the presence of high concentration CO2. Combustion and pyrolysis of a density fractionated China coal at drop tube furnace yielded the following conclusions. Compared to oxy-chars obtained under pure CO2 atmosphere, the swelling ratios of char obtained in pure N-2 atmosphere are higher. When adding 5% O-2, experimental results are completely different with those of the pyrolysis experiment. In comparison with the oxy-chars obtained under CO2 + 5%O-2 atmosphere, the swelling ratios of the char obtained in N-2 + 5%O-2 atmosphere are lower. In the pyrolysis experiment, the BET surfaces Area of the oxy-chars are about ten to twenty times as much as chars. When adding 5% O-2, the BET surfaces Area of the oxy-chars are about two to four times as much as chars. During pyrolysis experiment, the total pore volumes of the oxy-chars obtained under pure CO2 are larger in comparison with chars obtained in pure N-2. The pore distributions of the oxy-chars are mainly mesopore and the chars have macropore mostly. The micropore and mesopore volume of oxy-chars are about ten times as much as chars separately and the macropore volume of oxy-chars are about two times as much as chars. When adding 5% O-2, the total pore volumes of the oxy-chars obtained under CO2 + 5%O-2 are also larger in comparison with chars obtained in N-2 + 5%O-2. In the pyrolysis experiment, the reactivity indexes of oxy-chars obtained under pure CO2 are lower in comparison with chars obtained in pure N-2. When adding 5% O-2, no significant differences can be observed, which may be due to the ordering of carbon microcrystalline structure. In pure CO2 atmosphere, the oxy-chars have a highly order polycrystalline structure, but chars obtained at pure N-2 atmosphere have a highly disordered carbonaceous structure.

Influence of microscopic structure properties of coal char on N2O formation and destruction

Effect of Char Properties on N2O Formation and Reduction During Circulating Fluidized Bed Coal Combustion

Combustion of coal char in a circulating fluidized bed

Mechanisms of the N2O formation and decomposition over coal char surface

Effect of Heterogeneous Reactions of Coal Char on Nitrous Oxide Formation and Reduction in a Circulating Fluidized Bed

Nitrogen oxides emission from coal char combustion

Study on the mechanism of N2O formation and decomposition of coal combustion in fluidized bed

Experimental and modeling investigation on char combustion and char-nitrogen evolution characteristics under different conditions

Effect of Char Particle Size on NO Release During Coal Char Combustion

Properties of char particles obtained under O2/N2 and O2/CO2 combustion environments

Effect of O2/CO2 combustion on coal char reactivity

Structure and combustion reactivity of coal char pyrolyzed in different atmospheres

Char Structural Evolution During Pyrolysis and Its Influence on Combustion Reactivity in Air and Oxy-Fuel Conditions

Experimental study on the co-firing and NOx emission characteristics of bituminous coal and its medium temperature pyrolysis char

Comparison Of Char Structural Characteristics And Reactivity During Conventional Air And Oxy-Fuel Combustion

Pm10 Formation During the Combustion of N-2-Char and Co2-Char of Chinese Coals

In situ experimental and modeling study on coal char combustion for coarse particle with effect of gasification in air (O2/N2) and O2/CO2 atmospheres

Pyrolysis of Superfine Pulverized Coal. Part 4. Evolution of Functionalities in Chars

Experimental study on effects of combustion atmosphere and coal char on NO 2 reduction under oxy-fuel condition

Combustion of Pulverized Coal in O2/CO2 Mixtures and Its Pore Structure Development

Structure and Reactivity of Chars Prepared from Low-Volatile Coal under O2/N2 and O2/CO2 Conditions in a Flat-Flame Assisted Entrained Flow Reactor