Abstract:Condensation of the water vapor present in the air is a heat and mass transfer process encountered in many applications as humid air dehumidification and water harvesting. Depending on the wettability characteristics of the surface, condensation can take place in filmwise mode or in dropwise mode with the formation of discrete liquid droplets over the condensing surface. While dropwise condensation (DWC) of pure steam was found to promote a considerable enhancement of the heat transfer compared to filmwise condensation, when dealing with humid air DWC more investigation is needed. Modeling of DWC from humid air requires the calculation of the heat flow rate through a single droplet and the determination of the drop-size distribution. The heat exchanged through a single droplet depends on the heat and mass transfer resistances, while the drop-size distribution is also affected by nucleation site density and droplets mobility. Therefore, to better understand the DWC phenomenon with humid air and for the validation of the models, it is necessary to measure the heat flux (total and latent), droplet population and nucleation site density. In the present work, condensation tests from humid air are performed over two square (40 mm x 40 mm) aluminum samples that display different wettability. The experimental apparatus consists of a closed air loop with two main components: the environmental chamber and the test chamber. The air is conditioned in the environmental chamber and then it flows inside the test section where the vapor present in the humid air is condensed over the vertical metallic sample. Two variable speed fans are used to circulate the air. The test section is designed for heat and mass transfer measurements and for simultaneous visualization of the condensation process. As a peculiar characteristic of the present experimental technique, all the test section assembly is suspended on a high precision balance allowing a precise measurement of the mass of condensate. The effect of surface wettability on the heat and mass transfer during DWC is investigated. Time-lapse videos of the condensation process are acquired at different magnifications. By using a homemade MATLAB ® program for droplet detection, recorded images are analysed allowing the determination of both the drop size density distribution (small and large droplet population) and the nucleation sites density.

Filmwise condensation heat transfer enhancement with dropwise and filmwise coexisting condensation surfaces

Biphilic jumping-droplet condensation

Dropwise Condensation Heat Transfer Of Steam On Polymer Coatings

Progress in implementation of dropwise condensation

Dropwise condensation heat transfer of the surface with micro columns

The condensation characteristics of individual droplets during dropwise condensation

Dropwise condensation: From fundamentals of wetting, nucleation, and droplet mobility to performance improvement by advanced functional surfaces

Advances in Dropwise Condensation Heat Transfer: Chinese Research

Coupling droplets/bubbles with a liquid film for enhancing phase-change heat transfer

Dropwise Evaporative Cooling of Heated Surfaces with Various Wettability Characteristics Obtained by Nanostructure Modifications

Review of droplet dynamics and dropwise condensation enhancement: Theory, experiments and applications

Lattice Boltzmann simulation of dropwise condensation on the microstructured surfaces with different wettability and morphologies

Investigation of filmwise condensation and flow characteristics on inner curved heat transfer surface

Enhanced steam condensation heat transfer on a honeycomb-like microporous superhydrophobic surface under different condensing pressures

Experimental analysis of drop size distribution and nucleation site density during dropwise condensation from humid air flow

Hierarchical microcavity topography for enhancement of water vapor condensation heat transfer by regulating droplet dynamics and droplet size distribution

Lattice Boltzmann Modeling of Condensation Heat Transfer on Downward-Facing Surfaces with Different Wettabilities

Dropwise Condensation Heat Transfer on Nanostructured Superhydrophobic Surfaces with Different Inclinations and Surface Subcoolings

Lifetime Test of Dropwise Condensation on Polymer-Coated Surfaces

Enhanced Moisture Condensation on Hierarchical Structured Superhydrophobic–Hydrophilic Patterned Surfaces

A Novel Continuous Drop-Wise Condensation Technology for Improved Heat and Mass Transfer Efficiencies