Abstract:Xylooligosaccharides (XOS) hold industrial importance owing to their prebiotic, antioxidant, antibiotic, and anti-inflammatory potential. The fungal enzyme xylanase ( Talaromyces thermophilus F1208) is known for its capacity to produce XOS by hydrolytic degradation. This study aims to achieve the maximum xylan yield through experiments by optimizing corn cob pyrolysate's parameters. The xylan in the pyrolysis solution was converted into XOS using the ultrasonic-coupled enzymolysis method and optimizing its parameters. Optimizing pyrolysis conditions employing maleic acid concentration, pyrolysis temperature, and holding time resulted in a maximum xylan yield (20.04%) at 0.2%, 180 °C, and 30 min of the three parameters, respectively. The multivariate response surface methodology (RSM) for pyrolysis statistically validated the results and suggested pyrolysis temperature and holding time to be the most crucial parameters influencing the yield. Similarly, the highest yield of XOS (21.75%) was obtained at 7.5 pH, 4-h reaction time, and 6-U/mL enzyme dosage for the enzyme hydrolysis alone by selecting these three as optimization parameters. In the case of enzyme hydrolysis coupled to ultrasonication, the maximum yield of 27% XOS was achieved at 190 °C pretreatment temperature, 30-min ultrasonication time, 55 °C ultrasonication temperature, and 0.31-W/cm 2 ultrasonication frequency, which was ~25% higher than that obtained using enzymatic hydrolysis alone. Moreover, ultrasonic intervention shortened the reaction time to 12.5% of the original time. The difference in enzymatic hydrolysis of xylan components (H 1 –H 5 ) after alcohol precipitation was also investigated. It was found that the H 2 and H 3 substrates were slow reaction xylans, which were not easy to be enzymatically hydrolyzed.

STUDY ON HYDROLYSIS OF PEAT FOR PREPARATION OF XYLOSE

A study on catalytic hydrolysis of peat

Influence of inorganic acids on the dehydration of fructose to 5-hydroxymethylfurfural over AlCl3 catalyst

Research on dissolution performances of peat

RESEARCH ON DILUTE ACID PRETREATMENT OF CORN STALKS IN PERCOLATION REACTOR

Hydrothermal pretreatment renders peat susceptible to enzymatic saccharification

High Temperature Dilute Acid Pretreatment of Coastal Bermuda Grass for Enzymatic Hydrolysis.

RESEARCH ON FABRICATING XYLITOL WITH THE WASTE LIQUID IN BIOMASS HYDROLYSIS BY HYDRICHLORIC ACID

STUDY ON THE HYDROLYSIS OF CORN STALKS USING DILUTE SULFURIC ACID AND CELLULESE

CONCENTRATED SULFURIC ACID-HYDROLYSIS OF WOOD CHIPS FOR GLUCOSE

Optimizing Xylose Production from Pinewood Sawdust Through Dilute-Phosphoric-acid Hydrolysis by Response Surface Methodology

Combination of solid acid and solvent pretreatment for co-production of furfural, xylooligosaccharide and reducing sugars from Phyllostachys edulis

Comprehensive investigation of multiples factors in sulfuric acid pretreatment on the enzymatic hydrolysis of waste straw cellulose

Optimization of Enzymatic Hydrolysis of Wheat Straw Pretreated by Alkaline Peroxide Using Response Surface Methodology

Optimization of formic acid hydrolysis of corn cob in xylose production

Kinetic Studies of Xylan Hydrolysis of Corn Stover in a Dilute Acid Cycle Spray Flow-Through Reactor

Comparative study on the mild pretreatment processes for enzymatic hydrolysis of wheat straw with high-solid loading

Pretreatment of Sweet Sorghum Stalk Using Dilute Acid

Optimization of pretreatment and enzymatic hydrolysis coupled with ultrasonication for the production of xylooligosaccharides from corn cob

THE INFLUENCE OF REACTION CONDITION ON DILUENT HYDROCHLORIC ACID HYDROLYSIS OF PINE

Experimental Study and Product Analysis of Lignocellulosic Biomass Hydrolysis under Extremely Low Acids