Abstract:The existence of droplets in an annular flow has a non-negligible influence on the mass transfer and heat transfer between phases, and a phase property, such as liquid viscosity, can dominate the droplet characteristics. However, the effects of liquid viscosity on droplets have not yet received sufficient attention. In this study, the distribution characteristics of droplets in a vertical annular flow with a liquid viscosity of 1–30 mPa·s are experimentally investigated using a particle dynamic analyzer. The results reveal that the diameter and momentum of the droplet undergo two different changes during the increase of liquid viscosity, μ L. In the low-liquid-viscosity range (μ L < 10 mPa·s), the diameter and momentum of the droplet increase significantly with an increase in viscosity, whereas in the high-liquid-viscosity range (μ L ≥ 10 mPa·s), their dependence on viscosity is considerably low. Owing to the different degrees of aggregation and fragmentation of droplets under different liquid viscosities, the radial evolution of droplets also show obvious distinctions. In addition, the slip ratio of the droplet velocity under different liquid viscosities is determined. When the liquid viscosity increases from 1 to 30 mPa·s, the droplet velocity decreases by 20.3% on average in the gas velocity range of 25–58 m/s, and small droplets have a relatively higher velocity and velocity range. Further, on the experiments show that the droplet deformation increases sharply with an increase in liquid viscosity because of the change in droplet generation mechanisms. The minimum proportion of the spherical droplet reduces to 9.2% at μ L= 30 mPa·s, indicating that the droplet cannot be simply regarded as spherical when calculating the mass and heat transfer with high liquid viscosity. Finally, the present results can assist in multiphase flow modeling under high-viscosity conditions.

Effect of Viscosity on the Hydrodynamics of Liquid Processes in Microchannels

Liquid-liquid Two-Phase Flow and Mass Transfer in T-shaped Micro-Channel Network

WATER-OIL FLOW IN SQUARE MICROCHANNELS WITH A CROSSED JUNCTION

EFFECTS OF INLET ARRANGEMENTS ON LIQUID-LIQUID FLOW PATTERNS IN CROSS-JUNCTION SQUARE MICROCHANNELS

Effect of Viscosity on Liquid–Liquid Slug Flow in a Step T-Junction Microchannel

Simulation Studies on Fluid Density Distribution of Micro-Flows in A Nano-Channel

Effect of Molecular Interactions Between the Solid Wall and Liquid on the Flow Properties in Microtubes

Hydrodynamics and Scaling Laws of Gas–Liquid Taylor Flow in Viscous Liquids in a Microchannel

Effects of Two-Phase Periodic Velocity on Droplet Coalescence Inside Microchannels

Influence of hydrodynamics on liquid mixing during Taylor flow in a microchannel

Hydrodynamic Characteristics of Liquid–liquid–liquid Three-Phase Flow in a Confined Microchannel

Effect of interface deformation on hydrodynamics of liquid–liquid two-phase flow in a confined microchannel

Experimental Studies of Droplet Formation Process and Length for Liquid–Liquid Two-Phase Flows in a Microchannel

Numerical and experimental investigation of dripping and jetting flow in a coaxial micro-channel

Mass Transfer in Liquid-Liquid Taylor Flow in a Microchannel: Local Concentration Distribution, Mass Transfer Regime and the Effect of Fluid Viscosity

Size effect on single-phase channel flow and heat transfer at microscale

Influence of Fluid Viscosity on Particle Separation in Microchannel

Experimental investigation on the distribution characteristics of droplets in annular flow with wide liquid viscosity range

Hydrodynamics of Liquid-Liquid Two-Phase Flow Accounting for the Coupling of Dean Vortices and Poiseuille Flow

Liquid-liquid two-phase viscous flow in coaxial microfluidic device

Study on Liquid-Liquid Two-Phase Flow Patterns in a T-Shaped Microchannel