Abstract:A series of experimental studies on the heat transfer characteristics of pool boiling were conducted aboard the Chinese satellite SJ-10 in April 2016. Ground comparative experiments under the same conditions were carried out using the same apparatus. FC-72 was used as the working fluid containing non-condensable gas. The total quasi-stable-state acceleration aboard satellite SJ-10 during its in-orbit flight is approximately 2 × 10 −6 g 0 . The integrated microheater fabricated by the microelectromechanical system (MEMS) technique was used to investigate the boiling characteristics. The boiling surface of the integrated microheater is on top of a flat plate quartz glass wafer substrate 2 mm thick, heated by a serpentine Pt thin film (main heater) below the substrate. The effective area of the boiling surface in direct contact with FC-72 is 5.5 mm in diameter. Ten temperature sensors are located around the boiling surface center and uniformly distributed in the circumferential direction. The experimental results show that single-phase convection could still be maintained under lower Rayleigh number conditions, showing consistency with the predictions based on the available correlations. The generated bubble volume determines the boiling state. At high liquid subcooling, the bubbles formed after the liquid vaporizes are relatively small, and steam condensation at the bubble cap promotes the phase change efficiency, which maintains nucleate boiling in microgravity. When subcooling is low, bubbles are larger and cover most of the heating surface, nucleate boiling is difficult to maintain, and the boiling becomes transition boiling. High liquid subcooling improves the heat transfer efficiency, thereby contributing to maintaining the progress of nucleate boiling in microgravity. However, boiling is less affected by liquid subcooling on the ground than in microgravity. A comparison of pool boiling curves between microgravity and normal gravity experiments indicates that nucleate boiling curves under the same subcooling partially overlap, while the heat flux corresponding to the initiation of the nucleate state is lower than that on the ground. In microgravity, lower liquid subcooling and higher heating power will result in larger bubble volumes and easier complete coverage of the heating surface, resulting in an easier transition from nucleate boiling to film boiling.

An experimental study on geysering phenomena induced by buoyancy in a heating system

Physics of a toy geyser

Experimental investigation on geysering induced intermittent flow oscillation

Numerical Study on Bubble Behaviour and Heat Transfer Characteristics of Subcooled Pool Boiling Based on Non-Empirical Boiling and Condensation Model

Modeling of CO2-driven cold-water geyser in the northeast Qinghai-Tibet plateau

Experimental and numerical investigation of the influence of groundwater flow on the borehole heat exchanger performance: A case study from Tangshan, China

Three-dimensional CFD simulation of geyser boiling in high-temperature sodium heat pipe

Study on Local Sub-Cooling Boiling in the Vertical Upward Pipe

2D Modelling and energy analysis of entrapped air-pocket propagation and spring-like geysering in the drainage pipeline system

Experimental Study of the Heat-Transfer Performance of an Extra-Long Gravity-Assisted Heat Pipe Aiming at Geothermal Heat Exploitation

An experimental and theoretical study of a CO2 ejector

Investigation on cryogenic geyser characteristics in rocket cryogenic pipelines with a horizontal section

Numerical study on effects of chamber design and multi-inlet on storm geyser

Experimental Study of a Ground Source Heat Pump System Using Vertical Concentric Tube Ground Heat Exchangers

Experimental study on discharge process of external-melt ice-on-coil tank Part 2: Temperature distribution

Experimental investigation on the characteristics of bubble growth and slide on a downward-facing heater surface in flow boiling

Numerical Investigation of Fluid Flow and Heat Transfer in a Doublet Enhanced Geothermal System with CO2 As the Working Fluid (CO2–EGS)

Experimental study on subcooled pool boiling of FC-72 on a flat plate in normal and microgravity

Numerical Analysis on Heat Transfer Characteristics and Buoyancy Effects of Supercritical Pressure Water in Vertical Tube

Investigation And Modeling Of The In-Tube Heat Transfer Of Fluids At Supercritical Pressure During Heating

Numerical study on temperature response of microheater and evolution characteristics of superheated zone under fast transient heating