Abstract:The authors propose the utilisation of a nine‐switch converter as an alternative to the conventional H‐bridge converter for implementing cascaded multilevel converters in dual electric motor drive systems. In order to address the issues of complexity, high cost, large volume, and low reliability associated with traditional H‐bridge cascaded converters when operating under high voltage, high capacity, and dual electric motor loads, the authors propose the utilisation of a nine‐switch converter as an alternative to the conventional H‐bridge converter for implementing cascaded multilevel converters in dual electric motor drive systems. After conducting an analysis and research on the topology and operational control strategy of cascaded multilevel converters based on the nine‐switch converter, a design is presented using six individual nine‐switch converter units to develop a cascaded multilevel converter capable of driving two 3 MW asynchronous electric motors at a 6 kV voltage level. Simulation verification is performed, and a scaled‐down prototype is built for experimental validation. The results demonstrate that, in comparison to traditional H‐bridge cascaded converters, the proposed cascaded multilevel converter can effectively drive dual electric motors at the same or different frequencies while reducing the number of switches to 1/4, the total transformer windings to 1/2, and Direct Current‐side capacitors to 1/6. This improvement enhances system reliability, portability, and load adaptability, thus offering increased versatility in dual electric motor drive applications.

Research on Back to Back Cascaded H-Bridge Converter Based on High Frequency Transformer

Modeling and Control Design of Grid-Forming Cascaded H-Bridge Converter

Cascaded Half-Bridge Multilevel Inverter with Reduced Number of Power Switches

Cascaded H7 Current Source Converter Based Power Transmission System And Fault Analysis

Three-Phase Seven-level H-bridge Commutated Active Clamped Converter

A Novel Modulation Scheme and a DC-Link Voltage Balancing Control Strategy for T-Type H-Bridge Cascaded Multilevel Converters

Research on a High Frequency Multi-Winding Transformer Isolated Multilevel Converter

Design of H-bridge Based Converter Module Used in Cascaded DSTATCOM

Research on cascaded multilevel converters for dual motor drive systems based on a nine‐switch converter

A novel transformerless cascaded multilevel converter topology

Control Strategy of Cascaded Multilevel Converter Based on Dual Active Bridge for Wind Energy Conversion System.

Study of Cascaded High Voltage AC-AC Converter for Marine Electric Propulsion System

Research on the HEV based power converter

A novel three-phase seven-level active clamped converter using H-bridge as a level doubling network

Improved Cascaded H-Bridge Multilevel Inverters with Voltage-Boosting Capability

A Hybrid ZVS Full-Bridge Converter with Transformer Winding Series-Parallel Auto Regulated Current Doubler Rectifier

Control of the Cascaded H-bridge Multilevel Matrix Converter

Dc-Link Ripple Suppression of Cascaded H-Bridge Based MV Grid Emulator Apparatus for Analysis and Testing of Grid-Tied Converters in Distribution System

Performance Evaluation of a Three- Phase Five-Level Quasi-Z-Source Cascaded H-Bridge for Grid-Connected Applications

A Medium-Voltage High-Power Cascaded Motor Drive System with Low Voltage Fluctuation in the DC Bus

A Dual Half-Bridge Converter With Current Doubler Rectifier