Abstract:Liquid-to-gas mass transfer in anaerobic processes was investigated theoretically and experimentally. By using the classical definition of k(L)a, the global volumetric mass transfer coefficient, theoretical development of mass balances in such processes demonstrates that the mass transfer of highly soluble gases is not limited in the usual conditions occurring in anaerobic fermentors (low-intensity mixing). Conversely, the limitation is important for poorly soluble gases, such as methane and hydrogen. The latter could be overconcentrated to as much as 80 times the value at thermodynamic equilibrium. Such overconcentrations bring into question the biological interpretations that have been deduced solely from gaseous measurements. Experimental results obtained in three different methanogenic reactors for a wide range of conditions of mixing and gas production confirmed the general existence of low mass transfer coefficients and consequently of large overconcentrations of dissolved methane and hydrogen (up to 12 and 70 times the equilibrium values, respectively). Hydrogen mass transfer coefficients were obtained from the direct measurements of dissolved and gaseous concentrations, while carbon dioxide coefficients were calculated from gas phase composition and calculation of related dissolved concentration. Methane transfer coefficients were based on calculations from the carbon dioxide coefficients. From mass balances performed on a gas bubble during its simulated growth and ascent to the surface of the liquid, the methane and carbon dioxide contents in the gas bubble appeared to be controlled by the bubble growth process, while the bubble ascent was largely responsible for a slight enrichment in hydrogen.

Hydrogen supersaturation in extreme-thermophilic (70°C) mixed culture fermentation

Hydrogen supersaturation in thermophilic mixed culture fermentation

The chemostat study of metabolic distribution in extreme-thermophilic (70 °C) mixed culture fermentation

Characterization of Microbial Compositions in a Thermophilic Chemostat of Mixed Culture Fermentation

The Glucose Metabolic Distribution in Thermophilic (55 °C) Mixed Culture Fermentation: A Chemostat Study

Microbial dynamics of the extreme-thermophilic (70 °C) mixed culture for hydrogen production in a chemostat

Enhancement of Fermentative Hydrogen Production in an Extreme-Thermophilic (70°C) Mixed-Culture Environment by Repeated Batch Cultivation

Role of hydrogen (H2) mass transfer in microbiological H2-threshold studies

Intensification of Hydrogen Production by a Co-culture of Syntrophomonas wolfei and Rhodopseudomonas palustris Employing High Concentrations of Butyrate as a Substrate

Synergistic Effect of Candida Maltosa HY-35 and Enterobacter Aerogenes W-23 on Hydrogen Production

Hydrogen and Carbon Dioxide Mixed Culture Fermentation in a Hollow-Fiber Membrane Biofilm Reactor at 25 °C

Enhancing Hydrogen Production Performance by Developing Thermotolerant Fermentative Mixed Consortium Via High Temperature Stress Acclimation

High Yield Simultaneous Hydrogen and Ethanol Production under Extreme-Thermophilic (70 °C) Mixed Culture Environment

Effect of C, N Source and mC/mN on Hydrogen-producing Characteristic of Fermentative H2-producing Strain RF-9

Stable Acetate Production in Extreme-Thermophilic (70°C) Mixed Culture Fermentation by Selective Enrichment of Hydrogenotrophic Methanogens

F52. A new method to calculate logarithmic damping factor in damped oscillation type rheometer

Extreme-thermophilic biohydrogen production from lignocellulosic bioethanol distillery wastewater with community analysis of hydrogen-producing microflora

Simultaneous Hydrogen and Ethanol Production from A Mixture of Glucose and Xylose Using Extreme Thermophiles I: Effect of Substrate and Ph

Xylose fermentation to biofuels (hydrogen and ethanol) by extreme thermophilic (70°C) mixed culture

Effect of Culture Conditions on Producing and Uptake Hydrogen Flux of Biohydrogen Fermentation by Metabolic Flux Analysis Method

Liquid-to-Gas Mass Transfer in Anaerobic Processes: Inevitable Transfer Limitations of Methane and Hydrogen in the Biomethanation Process