Abstract:Pressurized oxy-coal combustion has received wide attention recently due to its potential of high efficiency and low cost in CO2 capture. However, there is still a significant knowledge gap on the effects of pressure on the oxycoal and oxy-char combustion behaviors. In this study, oxy-char combustion experiments were carried out in a pressurized fluidized bed combustor, and the effects of pressure and oxygen concentration on the burnout time, reactivity and temperature of the char particles were investigated. The experimental results showed that the burnout time of the char particles decreased significantly with an increase in pressure from 0.1 MPa to 0.5 MPa. Besides, an increase in either the combustion pressure (within the range of 0.1 - 0.5 MPa) or the oxygen concentration (within the range of 10 - 30% O-2 in CO2) led to increases in the reactivity and temperature of the char particles, while the promotional effects of the pressure increase were weaker at the higher pressures. In order to better interpret the experimental results, a combustion model considering reaction kinetics, mass and heat transfer, and energy balance was developed and validated by the experimental results. The model simulation results showed that an increase in pressure would reduce the burnout time of char particles only when the combustion was kinetically controlled or combined kinetic-diffusion controlled. Once the combustion became diffusion-controlled, a further increase in pressure would have an insignificant effect on the char burnout time. Although the values of kinetic constants were different when different kinetic models, the global power-law model and Langmuir-Hinshelwood model, were adopted, the simulation results of the burnout time of the char particle under the pressurized fluidized bed combustion conditions were almost the same since the char combustion was mainly diffusion-controlled. The elevated combustion pressure accelerated both the char combustion rate and the char-CO2 gasification rate, while the carbon consumption ratio by gasification increased with pressure. Moreover, the enhanced gasification reaction had a great impact on the particle temperature especially under the higher oxygen concentration combustion conditions.

Effect of Stefan Flow on Heat Balance of a Char Particle in Oxy-Fuel Combustion

Effects of Stefan Flow on Ignition and Heat Transfer of A Char Particle in O-2/Co2 Atmospheres

Combustion model of a char particle considering Stefan flow effects in O2/CO2 atmosphere

Effects of Stefan Flow and CO Oxidation on Char Particle Combustion in O2/CO2 Atmosphere

Mass Transfer Coefficients Considering Effects of Steam in Oxy-Fuel Combustion of Coal Char

Mass Transfer Coefficients Considering Boundary Layer Reaction in Oxy-Fuel Combustion of Coal Char

Correction to Mass Transfer Coefficients for the Combustion of a Char Particle in O2/CO2/H2O Atmosphere

Insight into the combustion effect of the high-reactivity char particle on the low-reactivity char particle in a hot O<sub>2</sub>/CO<sub>2</sub> atmosphere

Reaction Kinetics of Char-O2/h2o Combustion under High-Temperature Entrained Flow Conditions

Effect of Stoichiometric Ratio on Char-Nitrogen Conversion under High-Temperature Entrained Flow Combustion Conditions

Oxy-fuel Combustion of a Single Fuel Particle in a Fluidized Bed: Char Combustion Characteristics, an Experimental Study

Insight into the combustion effect of the high-reactivity char particle on the low-reactivity char particle in a hot O 2 /CO 2 atmosphere

Experimental Study and Modeling of Oxy-Char Combustion in a Pressurized Fluidized Bed Combustor

Effect of Stoichiometric Mixture Fraction on Soot Fraction and Emission Spectra with Application to Oxy-Combustion

Numerical Investigation of Different Effects of Carbon Dioxide Properties and Carbon Monoxide Oxidation on Char Particle Combustion in Actual and Fictitious O2/CO2 Environments

Correction to Mass Transfer Coefficients Considering Volumetric Reaction in Boundary Layer of a Char Particle in O_2/CO_2

Experimental and Modeling Investigation of Oxy-Coal Combustion Based on Langmuir-Hinshelwood Kinetics and Direct Calculation of Char Morphology

Modeling of Single-Particle Char Combustion under O2/H2O Conditions: Effects of Temperature and Steam Concentration

Soot Formation Characteristics in Laminar Coflow Flames with Application to Oxy-Combustion

Influence of Volatile Flame on Combustion of Char Particle

Study On The Effect Of Volatile Flame On The Combustion Of A Char Particle