Abstract:Recent decades have seen a growing concern about ever-increasing green house gas (GHG) emissions and depletion of fossil fuels. Polygeneration, a multi-input multi-output energy system, provides huge opportunities to tackle these problems due to its superior performances over conventional energy systems in terms of energy conversion efficiency and GHG emissions. Many approaches have been made in process design and analysis of polygeneration energy systems, but most of them focus on using coal gasification as the only way to provide gas for downstream utilization. Coke oven gas, another gas source with huge capacity, however, has not received enough attention in polygeneration process design, and researches in this field are still rather limited. In this paper, we present a dual-gas sourced polygeneration process design which uses both gasification gas and coke oven gas and produces methanol, dimethyl ether (DME), and dimethyl carbonate (DMC) in an integrated catalysis procedure. Gasification gas and coke oven gas are converted to synthesis gas, or syngas, via a catalytic reforming procedure, where the ratio between carbon monoxide and hydrogen in the syngas is carefully adjusted according to specific requirements of downstream chemical synthesis reactions. An integrated catalysis procedure follows, where DME is synthesized from the fresh syngas first, unconverted syngas is then sent to a methanol synthesis unit to produce methanol, and part of the methanol is further converted to DMC in a DMC synthesis unit. Based on the proposed process design, an exergoeconomic analysis and an exergy cost distribution diagram are presented, from which the production cost of a product over each functional block of the process can be easily obtained. Analysis results show that the largest exergy loss occurs in an exothermic reformer, accounting 60.4 percent of the total exergy loss. The exergy cost distribution diagram indicates that DMC has the highest exergy cost, followed by DME and methanol, and it is economically favorable to use the exhaust gas from the chemical synthesis block for power generation.

Design and Optimization of Methanol-Power Polygeneration Based on Coal Gas and Coke-Oven Gas

Design and Analysis of Dual Fuel Methanol-Power Poly-Generation

Techno-economic evaluation for coal-based polygeneration systems of heat, power, oil and synthetic natural gas

Optimal Design and Thermodynamic Analysis on the Hydrogen Oxidation Reactor in a Combined Hydrogen Production and Power Generation System Based on Coal Gasification in Supercritical Water

Energy and Exergy Analysis of Poly-Generation System of Hydrogen and Electricity Via Coal Partial Gasification

Analysis of the Polygeneration System of Methanol and Electricity Based on Coal Gasification (2)

Techno-economic Analysis of Methanol and Electricity Poly-Generation System Based on Coal Partial Gasification

A Study of Methanol Synthesis,Distillation Simulation and Load Variation of a Methanol/Power Cogeneration System

A multi-objective optimization approach to polygeneration energy systems design

Research on DME-power co-generation from coal gas and coke-oven gas

Low-rank Coal Pyrolysis Polygeneration Technology with Semi-Coke Heat Carrier Based on the Dual-Fluidized Bed to Co-Produce Electricity, Oil and Chemical Products: Process Simulation and Techno-Economic Evaluation

Integrating Low Steam Demand CO Shift Process to Coal Based Polygeneration Energy Systems: Process Design and Analysis

A novel process design and techno-economic analysis for coal-based polygeneration process of synthetic natural gas, methanol and power

Study on Off-design Performance of Series Polygeneration System with Liquid Phase Methanol Synthesis

A dual-gas sourced integrated methanol/DME/DMC catalysis approach to polygeneration energy systems design and an exergoeconomic analysis

Feasibility and Performance Analysis of a Dual‐Regulation System in the Process of Methanol and Electricity Coproduction by Coal Gasification

Conceptual Design and Techno-economic Analysis of a Coal to Methanol and Ethylene Glycol Cogeneration Process with Low Carbon Emission and High Efficiency

Exergy Analysis of Methanol-Igcc Polygeneration Technology Based on Coal Gasification

Research on CO2 Mitigation Specialty Equation of "double Gas" Polygeneration System

RESEARCH ON FLOWSHEET DESIGN OF MEDIUM SCALE DOUBLE GAS POLYGENERATION DEVICE

Simulation and exergoeconomic analysis of a dual-gas sourced polygeneration process with integrated methanol/DME/DMC catalytic synthesis