Abstract:An in-depth insight into the pyrolysis characteristics of tobacco is of great significance for the utilization of tobacco wastes. The effects of glycerol addition on the pyrolysis characteristics and distribution of aroma components of four types of tobacco was investigated in this study by using thermogravimetry and self-built rapid heating furnace capture and GC-MS analysis. Further, correlation network analysis was used to study the correlation between pyrolysis characteristics and released aroma components. It was found that the thermal weight loss behavior of different samples exhibited both commonalities and differences, the thermal weight loss process could be divided into four stages. After the application of glycerol, the overall performance of all types of tobacco leaves at stage II showed that DTG max2 and WL 2 increased, and glycerol had a relatively obvious effect on the pyrolysis characteristic parameters of flue-cured tobacco. Pyrolysis kinetic analysis based on Coats-Redfern method showed that the activation energy and pre-exponential factor of tobacco samples were decreased after the addition of glycerol. Under the heating condition, the total amount of released aroma components from each type of tobacco followed the order of burley tobacco > flue-cured tobacco >oriental tobacco > yellow sun-cured tobacco. The release amount of heterocyclic and olefins compounds from burley tobacco were higher, while flue-cured tobacco released higher contents of esters, ketones and furans compounds. The addition of glycerol promoted the release of aroma components. In terms of correlation, T max2 was negatively correlated with esters, aldehydes, and furans compounds, and positively correlated with DTG max3 . T max3 was significantly correlated with a lot of indicators, positively with acids, aldehydes, and furans compounds, but negatively with olefins and heterocyclic compounds.

Effect of Urea Phosphate on Thermal Decomposition of Reconstituted Tobacco and CO Evolution

Influence of Ammonium Polyphosphate on Thermal Decomposition of Reconstituted Tobacco and CO Evolution

Thermal Degradation and Combustion Behavior of Reconstituted Tobacco Sheet Treated with Ammonium Polyphosphate

Effects of melamine phosphate on the thermal decomposition and combustion behavior of reconstituted tobacco sheet

Chemical Mechanism of Exhaust Gas Recirculation on Polycyclic Aromatic Hydrocarbons Formation Based on Laser-Induced Fluorescence Measurement

Studies on Thermal Behavior of Reconstituted Tobacco Sheet

The Effect of Oxygen on In-Situ Evolution of Chemical Structures During the Autothermal Process of Tobacco

Mechanism Study of Tobacco Pyrolysis Based on the Analysis of Characteristic Products and In-Situ Identification of Functional Groups Evolution on Pyrolytic Char

Effects of Ammonium Polyphosphate on Pyrolysis-Combustion Characteristics and Sensory Quality of Paper-making Process Reconstituted Tobacco Sheet

Effect of potassium organic and inorganic salts on thermal decomposition of reconstituted tobacco sheet

Pyrolysis characteristics of different types of tobacco and its correlation with the released aroma components under heating condition

Experimental and Kinetic Studies on Tobacco Pyrolysis under a Wide Range of Heating Rates

Mass Loss and Evolved Gas Analysis in Thermal Decomposition of Solid Urea

Research on the Pyrolysis Mechanism of Tobacco Based on Low Temperature Torrefaction

Multiple analyses of main flavor components in reconstituted tobacco and transfer behavior of their key substances during heating

Effect of glycerol addition and heating rate on the thermal release behavior of cigar tobacco

Pyrolysis Behavior of Paper-base of Paper-making Process Reconstituted Tobacco with Different Physical Parameters under Flash Pyrolysis Conditions

Investigation on Pyrolysis and Carbonization of Eupatorium Adenophorum Spreng and Tobacco Stem

TG-FTIR study on urea-formaldehyde resin residue during pyrolysis and combustion.

Quantitative Evaluation of Co Yields for the Typical Flue-Cured Tobacco under the Heat-Not-Burn Conditions Using Sstf

Applications of Thermal Stepwise Reactions on the Co-Gasification of Coal and Tobacco Stems