Abstract:Chlorella sp., as a kind of microalgae with high proteins content and rigid cell walls, is a potential material for proteins recovery as poultry feed supplement source. This study proposed an algal biorefinery paradigm for sequent production of proteins and biogas from microalgae Chlorella sp. via CO2 assisted hydrothermal treatment and anaerobic digestion. The CO2 could be sustainably refilled as being a bioproduct of biogas. As a widely-used environmentally benign hydrothermal catalyst, the addition of CO2 could reduce treatment temperature and CO2 is easily removed by depressurizing. Microalgal cells were more disrupted with rising temperature from 70 degrees C to 150 degrees C, which facilitated the recovery of proteins. The recovery of proteins increased from 6.32% to 69.81%. After proteins recovery, the C/N ratio of microalgal residues was significantly higher than the untreated Chlorella sp. The process of proteins recovery could relieve the hydrolysis limitation of cell walls but reduce organics remained in microalgal residues. Biomethane production from microalgal residues exhibited a similar rising trend to proteins recovery. The highest cumulative biomethane production of 194.63 mL/gVS was achieved for the group at 130 degrees C, and the lowest value of 104.42 mL/gVS was obtained for the group at 70 degrees C. Excess microalgal cells disruption and side reactions led to the poor biomethane performance for the group at 150 degrees C, consistent with the decreased proteins recovery. During anaerobic digestion, the concentration of acetic acid distributed in a range of 0.05-0.44 g/L, which was dominant among total volatile fatty acids. The proteins as poultry feed supplement would be preferable to be considered as the main product, and the biomethane was considered as the side product. Carbon balance analysis revealed that most groups could basically meet the CO2 demand for HTT except the group at 150 degrees C. 130 degrees C was considered as the favorable treatment temperature level, leading to a proteins yield of 0.41 g/gVS and biomethane yield of 91.47 mL/gVS by Chlorella sp. (C) 2020 Elsevier Ltd. All rights reserved.

Bacterial bioaugmentation for improving methane and hydrogen production from microalgae

Enhancement of microbial diversity and methane yield by bacterial bioaugmentation through the anaerobic digestion of Haematococcus pluvialis

Bioaugmentation with Ruminiclostridium Thermocellum M3 to Enhance Thermophilic Hydrogen Production from Agricultural Solid Waste

Enhanced Methane Production from Microalgal Biomass by Anaerobic Bio-Pretreatment.

Improving fermentative hydrogen and methane production from an algal bloom through hydrothermal/steam acid pretreatment

Biohydrogen Production by a Novel Integration of Dark Fermentation and Mixotrophic Microalgae Cultivation

Unlocking synergies: Harnessing the potential of biological methane sequestration through metabolic coupling between Methylomicrobium alcaliphilum 20Z and Chlorella sp. HS2

Cogeneration of Hydrogen and Methane from the Pretreated Biomass of Algae Bloom in Taihu Lake

Power Generation Enhancement in Novel Microbial Carbon Capture Cells with Immobilized Chlorella Vulgaris

Enhancement of Methane Production by Addition of Clostridium Thermocellum in the Anaerobic Digestion of Switchgrass

Microalgal upgrading of the fermentative biohydrogen produced from Bacillus coagulans via non-pretreated plant biomass

Bioaugmentation with Thermoanaerobacterium Thermosaccharolyticum W16 to Enhance Thermophilic Hydrogen Production Using Corn Stover Hydrolysate

Enhanced biofuel production from high-concentration bioethanol wastewater by a newly isolated heterotrophic microalga, Chlorella vulgaris LAM-Q.

Microalgae cell disruption and lipid composition and recovery improvements induced by algicidal effects of bacteria

Nutrient removal and biogas upgrade using co-cultivation of Chlorella vulgaris and three different bacteria under various GR24 concentrations by induction with 5-deoxystrigol

Sequent production of proteins and biogas from <i>Chlorella</i> sp. via CO<sub>2</sub> assisted hydrothermal treatment and anaerobic digestion

Stimulating Methane Production from Microalgae by Alkaline Pretreatment and Co-Digestion with Sludge

Applicability of blue algae as an activator for microbial enhanced coal bed methane technologies

Mixotrophic Cultivation of Green Algal Aggregates Boost Photobiological Hydrogen Production

Simultaneous purification of anaerobic digestion slurry and enhancement in produced biogas using different microalgae-based technologies under a variety of mixed light wavelengths and photoperiods

A novel two-stage immobilized bioreactor for biohydrogen production using a partial microalgal-bacterial ( Chlorella vulgaris and wastewater activated sludge) co-culture