Abstract:The pyrolysis of corn stalk was performed with thermogravimetry (TG), and its liquefaction was investigated in a semicontinuous apparatus with a nonisothermal fluid extraction technique, both with and without sodium carbonate (Na2CO3) as a catalyst. The results indicated that the main pyrolysis region of corn stalk is similar to500-650 K and the maximum rate occurs at similar to600 K on the differential thermogravimetry (DTG) curve. The presence of a catalyst has an obvious effect on the pyrolysis, especially in the temperature range of 550-650 K. When more than 1.0 wt % of catalyst was added, the DTG curve is altered greatly, from two peaks to one, for the catalyst, which has a greater effect on hemicellulose than on cellulose and lignin. Kinetic analysis shows that the activation energy in the main pyrolysis range (10-70 wt %) varies with different amounts of catalyst addition. The liquefaction conversion of corn stalk with 3 mL/min of water as a solvent at a pressure of 25 MPa, with or without the addition of 1.0 wt % of Na2CO3, is up to 95.7 and 95.4 wt %, respectively. The catalyst mainly improved the yield of bio-oil, from 33.4% without a catalyst, increasing to 47.2% with 1.0 wt % of Na2CO3. The catalyst has a positive effect on the liquefaction at relatively higher temperatures and can increase the yield of liquid product, as well as improve the quality of liquid product. More bio-oil and less gas can be obtained with a catalyst than that without a catalyst. A two-stage main reaction may occur for both the pyrolysis and liquefaction of corn stalk under the experimental conditions.

Effects of Chemical Inhomogeneity of Corn Stalk on Solvolysis Liquefaction

Differences in catalytic liquefaction kinetics of corn stalk fractions

Study on Liquefied Characteristics of Different Sections of Corn Stalk

Effects of chemical inhomogeneity on pyrolysis behaviors of corn stalk fractions

Rapid Liquefaction of Corn Stover with Microwave Heating

Liquefaction of Corn Stalk Using Multi-composite Solvent

Greater Importance of Structural Changes Over Lignin Removal in Impacting the Enzymatic Hydrolysis of Crop Straws

Experimental Study on the Liquefaction of Corn Cob and Qualitative Analysis of Its Products

Study on the Liquefaction Technology of Corn Stalk-Biomass Materials

Liquefaction of Cornstalk in the Presence of Polyhydric Alcohols

Research on the Corn Stalk Composite Solvent Liquefaction

A Single Step Fractionation of Lignocellulose in Aqueous Solutions of a Carboxylic Acid-Functionalized Ionic Liquid

Study on Mechanisms of Liquefied Corn Bran by FT-IR

Physicochemical properties of corn stalk after treatment using steam explosion coupled with acid or alkali

Effects of different pretreatment methods on chemical composition of corn stover hydrolysate

Experimental study on the liquefaction of corn stalk in sub-and supercritical ethanol-water

Rheological characterization of ball-milled corn stover with different fragmentation scales at high-solids loading

Study on the Multicomponent Catalytic Liquefaction Technology of Corn Stalk Features

Effects of Different Pretreatment Modes on the Enzymatic Digestibility of Corn Leaf and Corn Stalk

Separation and characterization of biomass components (cellulose, hemicellulose, and lignin) from corn stalk

Nonisothermal Catalytic Liquefaction of Corn Stalk in Subcritical and Supercritical Water