Abstract:Cellulosic material is the most abundant renewable carbon source in the world. Cellulose may be hydrolyzed using cellulase to produce glucose, which can be used for production of ethanol, organic acids, and other chemicals. Cellulase is a complex enzyme containing endoglucanase (EC 3.2.1.4), exoglucanase (EC 3.2.1.91) and cellobiase (EC 3.2.1.21). The hydrolysis of natural cellulose to glucose depends on the synergism of these three components. The mostly used cellulase produced by Trichoderma reesei has high activity of endoglucanase and exoglucanase, but the activity of cellobiase is relatively low. Therefore, improving the activity of cellobiase in cellulase reaction system is the key to enhance the sacchrification yield of cellulosic resources. Aspergillus niger LORRE 012 was a high productivity strain for cellobiase production. It was found that the spores of this strain were rich in cellobiase. In this work, the cellobiase was immobilized efficiently by simply entrapping the spores into calcium alginate gels instead of immobilizing the pure cellobiase proteins. The immobilized cellobiase was quite stable, and its half-life was 38 days under pH 4.8, 50 degrees C. The thermal stability of the immobilized cellobiase was improved, and it was stable below 70 degrees C. The suitable pH range of the immobilized cellobiase was pH 3.0 - 5.0, with the optimal pH value 4.8. The Km and Vmax value of the immobilized cellobiase were 6.01 mmol/L and 7.06 mmol/min x L, respectively. In repeated batch hydrolysis processes, 50 mL of substrate (10 g/L cellobiose) and 10 mL of immobilized beads containing cellobiase were added into a 150 ml flask. After reacting at pH 4.8, 50 degrees C for several hours, the hydrolysate was harvested for assay, and the immobilized beads were used for the next batch hydrolysis with the fresh substrate. This process was repeated, and the yield of enzymatic hydrolysis kept higher than 97% during 10 batches. The continuous hydrolysis process was carried out in a column reactor (inside diameter 2.8 cm, inside height 40 cm) packed with the immobilized beads. Using 10 g/L cellobiose as substrate, the hydrolysis yield reached 98% under 0.4 h (-1) dilution rate and pH 4.8, 50 degrees C. After corncob was treated by 1% dilute acid, the cellulosic residue (100 g/L) was used as substrate, and hydrolyzed by the cellulase (15 IFPU/g substrate) from Trichoderma reesei, at pH 4.8, 50 degrees C for 48 h. The concentration of reducing sugar in the hydrolysate was only 48.50 g/L (hydrolysis yield 69.5%). When the hydrolysate was further treated by the immobilized cellobiase, the cellobiose was hydrolyzed into glucose, and the feedback inhibition caused by the cellobiose accumulation disappeared sharply. By the synergism of immobilized cellobiase and the cellulase from T. reesei left in the hydrolysate, other oligosaccharides were mostly converted to monosaccharides. At 48 h, the reducing sugar concentration was increased to 58.78 g/L, the hydrolysis yield of the corncob residue was improved to 84.2%, and the ratio of the glucose in the total reducing sugar was increased from 53.6% to 89.5%. The reducing sugars converted from corncob could be used further in the fermentation of valuable industrial products. This research results were meaningful in the conversion and utilization of renewable biomass.

Biodegradation of Cellulose in Novel Recyclable Aqueous Two-Phase Systems with Water-Soluble Immobilized Cellulase

Enzymatic hydrolysis of biomass with recyclable use of cellobiase enzyme immobilized in sol–gel routed mesoporous silica

[Studies on Immobilized Cellobiase].

Synergetic Saccharification and Lactic Acid Fermentation by Coimmobilized Cells Using Cellulosic Materials

Simultaneously Saccharification and Lactic Acid Fermentation for Using Cellulosic Material As Raw Material in a Coupling Bioreactor

UCST-Type Soluble Immobilized Cellulase: A New Strategy for the Efficient Degradation and Improved Recycling Performance of Wastepaper Cellulose

Facile Construction of Synergistic Β-Glucosidase and Cellulase Sequential Co-immobilization System for Enhanced Biomass Conversion

Partition of Tea Saponin with a Novel Recyclable Thermo-pH Aqueous Two-Phase Systems

Development of pH-responsive polymer and citrate aqueous two-phase system for extractive bioconversion of cefprozil

Reversible immobilization of enzyme on the "deck" for high-efficiency heterogeneous catalysis

A study on the enzymatic properties and reuse of cellulase immobilized with carbon nanotubes and sodium alginate

Layered Co-Immobilization of Β-Glucosidase and Cellulase on Polymer Film by Visible-Light-Induced Graft Polymerization

The synthesis of a UCST-type zwitterionic polymer for the efficient recycling of cellulase at room temperature

Reversible immobilization of cellulase on gelatin for efficient insoluble cellulose hydrolysis

Cellulose-based functional polycarbonates as degradable enzyme carriers

Efficient degradation of polyacrylate containing wastewater by combined anaerobic–aerobic fluidized bed bioreactors

Optimization of an aqueous two-phase extraction method for the selective separation of sulfated polysaccharides from a crude natural mixture

Co-immobilized multi-enzyme biocatalytic system on reversible and soluble carrier for saccharification of corn straw cellulose

Optimization of Aqueous Two-Phase Systems for the Recovery of Soluble Proteins from Tannery Wastewater Using Response Surface Methodology

Efficient Enzymatic Hydrolysis and Polyhydroxybutyrate Production from Non-Recyclable Fiber Rejects from Paper Mills by Recombinant Escherichia coli

Rational design of temperature‐responsive binary polymers containing sulfobetaine and quaternary ammonium fragments for application in lignocellulosic hydrolysis