Abstract:Glycerol is a versatile platform compound that is formed in considerable amounts as a by-product of biodiesel production. The catalytic selective hydrogenolysis of glycerol to 1, 3-propanediol (1, 3-PDO) provides a sustainable route for the synthesis of this important diol. In this study, a series of platinum-tungsten oxide (Pt-WOx) catalysts with different WOx surface densities dispersed on titanium(IV) oxide, zirconium(IV) oxide, and aluminum oxide supports were prepared and evaluated for the glycerol hydrogenolysis to 1, 3-PDO. The highest reaction activity and 1, 3-PDO selectivity were achieved at a WOx density of approximately 1.5-2.0 W.nm(-2), with all three support materials. Such a strong dependence on the surface density of WOx revealed the critical role of the dispersed WOx domains in the hydrogenolysis of glycerol to 1, 3-PDO. The infrared spectra for carbon monoxide adsorption confirmed the electron transfer and strong interaction between the Pt particles and WOx domains. These phenomena were hypothesized to contribute to the superior selectivity to 1, 3-PDO over 1, 2-PDO of the supported Pt-WOx catalysts when compared with the corresponding supported Pt catalysts. The realized superior 1, 3-PDO selectivity was consistent with its higher stability on the Pt-WOx catalysts, as reflected by the lower reaction rate constant of 1, 3-PDO than those of 1, 2-PDO and glycerol obtained in their hydrogenolysis reactions. There existed a volcano-type dependence of the glycerol reaction activity on the hydrogen partial pressure. Such a dependence, together with the measured ratio (1 : 2) of the secondary to the primary C-H bonds in 1, 3-PDO in the presence of deuterium and deuterium oxide (replacing hydrogen and water, respectively), indicated that the glycerol hydrogenolysis proceeds by the kinetically relevant dehydrogenation of glycerol to the glyceraldehyde intermediate, followed by the dehydration and hydrogenation of glyceraldehyde to 1, 3-PDO over the Pt-WOx catalysts.

Catalytic Production of 1,2-Propanediol from Glycerol in Bio-Ethanol Solvent.

Selective Hydrogenolysis of Glycerol to 1,2-Propanediol Catalyzed by Supported Bimetallic PdCu-KF/γ-Al2O3

Hydrogen-free Synthesis of 1,2-Propanediol from Glycerol over Cu–Mg–Al Catalysts

Biodiesel Derived Glycerol Hydrogenolysis to 1,2-Propanediol on Cu/Mgo Catalysts

Catalytic Dehydration of 2,3-Butanediol over P/Hzsm-5: Effect of Catalyst, Reaction Temperature and Reactant Configuration on Rearrangement Products

Pt/Wo3/Zro2-Catalyzed Selective Hydrogenolysis Of Glycerol To Produce 1,3-Propanediol

Progress in Production of 1, 3-propanediol From Selective Hydrogenolysis of Glycerol

Recent Progress in Catalyst Development of the Hydrogenolysis of Biomass-Based Glycerol into Propanediols-A Review

Research on Hydrogenolysis of Glycerol to 1, 2-Propylene Glycol by Using Supported Raney-Cu/Al 2 O 3

Application of Co-Al Catalysts in Hydrogenation of Glycidol to 1,3-Propanediol

Hydrogenolysis of glycerol to 1,2-propanediol over Cu-based catalysts: A short review

Hydrogenolysis of Glycerol on Bimetallic Pd-Cu/solid-base Catalysts Prepared Via Layered Double Hydroxides Precursors

Highly efficient TiO2-supported Co–Cu catalysts for conversion of glycerol to 1,2-propanediol

Direct production of ethanol with high yield from glycerol via synergistic catalysis by Pd/CoOx and Cu/SBA-15

Selective Hydrogenolysis of Glycerol to 1,3-Propanediol over Supported Platinum-Tungsten Oxide Catalysts

Selective hydrogenolysis of raw glycerol to 1,2-propanediol over Cu–ZnO catalysts in fixed-bed reactor

Research progress of catalyst in catalytic hydrogenolysis of glycerol to 1,2-propanediol

Efficient Catalytic Hydrogenolysis of Glycerol Using Formic Acid As Hydrogen Source

Understanding the catalytic performance and deactivation behaviour of second-promoter doped Pt/WO x /γ-Al 2 O 3 catalysts in the glycerol hydrogenolysis for selective and cleaner production of 1,3-propanediol

Reforming and Hydrogenolysis of Glycerol over Ni/ZnO Catalysts Prepared by Different Methods

The Effect of WO3 on the Selective Hydrogenolysis of Glycerol to 1,3-Propanediol over Pt/WO3–Al2O3 Catalysts