Abstract:The cycle-to-cycle variations (CCVs) in reciprocating internal combustion engines may cause negative influence on diving performance, fuel economy, and emissions. Especially, lean-burn technology or exhaust gas recirculation (EGR) was used to improve engine combustion efficiency and reduce NOx, and the combustion boundary was limited by increased CCVs. Therefore, it was important to identify the complex dynamics of CCVs and to take measures for inhibiting them. The CCVs based on indicated mean effective pressure (IMEP) time series were examined in a lean-burn natural gas engine with a non-uniform pre-mixture based on statistical and multifractal theories. Tests were conducted at an engine speed of 1000 rpm and low loads of 10% and 25%, and combustion data at an engine load of 10% were analysed in detail because the CCVs are less sensitive to changes of gas injection timing (GIT) at the higher engine load. The nonlinear dynamics of the CCVs was revealed at the different GIT from 1° to 120°CA ATDC. The statistical properties of IMEP time series were characterised by distributions of probability density functions (PDF), the multifractal complexities of the combustion fluctuations were quantitatively analysed by the singularity spectra in terms of the Hölder exponent based on the theory of wavelet transform modulus maxima, and the primary source leading to the increased CCVs and complex dynamics in a natural gas engine with a non-uniform pre-mixture was identified using 3D-computational fluid dynamics simulations. Results show that as the GIT increased, the kurtosis of the IMEP time series systematically decreased from 592 to 1.8, the fast dynamics transitions from super-Gaussian to quasi-Gaussian distributions in combustion system were revealed, and the lower value of kurtosis implied the lower degree of intermittency. Except for the GIT of 60°CA ATDC, the value of the Hölder exponent h0>0.5documentclass[12pt]{minimal}usepackage{amsmath}usepackage{wasysym}usepackage{amsfonts}usepackage{amssymb}usepackage{amsbsy}usepackage{mathrsfs}usepackage{upgreek}setlength{oddsidemargin}{-69pt}egin{document}$$h_{0} > 0.5$$end{document}, which implies that the CCVs for the other GITs behaved like a persistent walk or positive correlation. For GITs of 60° and 90°CA ATDC, the narrow broadness of the singularity spectrum implicated a monofractality, while the obvious multifractal properties could be identified for the other GITs. The transitions of the dynamic behaviours may be caused by the degree of mixture in-homogeneity combined with a new mechanism of “prior-cycle effects” proposed in this paper, and the effect mechanism was not only associated with the residual gas in the cylinder but also with the residual gas fuel in the intake port, rather than independent effect of residual gas in cylinder reported in previous researches. Our research results provided the deeper understanding on the dynamics of combustion system in multi-point injection natural gas engines and may be beneficial to achieve nonlinear prediction and to develop improved control strategies for inhibiting the CCVs.

Cycle-to-cycle Variation Analysis of In-Cylinder Flow in a Gasoline Engine with Variable Valve Lift

Investigation of the Effect of the In-Cylinder Tumble Motion on Cycle-To-Cycle Variations in A Direct Injection Spark Ignition (disi) Engine Using Large Eddy Simulation (Les)

The Interactions of In-Cylinder Flow and Fuel Spray in a Gasoline Direct Injection Engine with Variable Tumble

An Investigation and Evaluation of Variable-Valve-timing and Variable-Valve-actuation Strategies in a Diesel Homogeneous Charge Compression Ignition Engine Using Three-Dimensional Computational Fluid Dynamics

Large-eddy Simulation of In-Cylinder Flow in a DISI Engine with Charge Motion Control Valve: Proper Orthogonal Decomposition Analysis and Cyclic Variation

Nonlinear dynamics of cycle-to-cycle variations in a lean-burn natural gas engine with a non-uniform pre-mixture

Large Eddy Simulation and Proper Orthogonal Decomposition Analysis of Turbulent Flows in a Direct Injection Spark Ignition Engine: Cyclic Variation and Effect of Valve Lift

Cfd Analysis Of Vvt/Vva On The Gas Exchange And Fuel-Air Mixing In A Diesel Engine

Dynamics of Cycle-to-cycle Variations in a Natural Gas Direct-Injection Spark-Ignition Engine

Computational Fluid Dynamics Simulation of In-Cylinder Flows in a Motored Homogeneous Charge Compression Ignition Engine Cylinder with Variable Negative Valve Overlapping

Dynamic Mode Decomposition for Extracting Cycle-to-Cycle Variation of SIDI Engine In-Cylinder Flow Under Motoring Condition

Study on Cycle-To-Cycle Variations of CAI Combustion Using NVO Strategy

Cyclic Analysis of In-Cylinder Vortex Interactions Based on Data-Driven Detection and Characterization Framework

Influence of Flash Boiling and Swirl Ratio on the Gasoline Spray Structure in a Spark-Ignition Optical Engine: an Experimental Study

Development and Validation of a Variable Displacement Variable Compression Ratio Miller Cycle Technology on an Automotive Gasoline Engine

Variable Valve Strategy Evaluation for Low-Load Operation in a Heavy-Duty Gasoline Compression Ignition Engine

Numerical Investigation of the Influence of Intake Valve Lift Profile on A Diesel Premixed Charge Compression Ignition Engine with A Variable Valve Actuation System at Moderate Loads and Speeds

Investigation of Cycle-To-Cycle Variation of In-Cylinder Engine Swirl Flow Fields Using Quadruple Proper Orthogonal Decomposition

Flow-pattern switching in a Motored Spark Ignition Engine

Cyclic Variations in a Lean-Burn Spark Ignition Engine Without and with Swirl

Cylinder-to-Cylinder Variations in a V6 Gasoline Direct Injection HCCI Engine