Abstract:Packed fixed-bed reactors are traditionally used for heterogeneous catalytic ozonation. However, a high solid-to-liquid requirement, poor ozone dissolution, ineffective utilization of catalyst surface area, and production of large amounts of catalyst waste impede application of such reactors. In this study, we designed a suspension catalytic ozonation reactor and compared the performance of this reactor with that of a traditional fixed-bed catalytic ozonation reactor employing oxalic acid (OA) as the target contaminant. Our results showed that total O3 dissolved into the suspension reactor (117-134 mg.L-1) was much higher compared to that measured in the fixed-bed reactor (53 mg.L-1) due to a higher O3(g) interphase mass transfer rate in the suspension reactor. In accordance with the higher O3(g) interphase mass transfer, we observed a much higher proportional OA removal (32 %) compared to that achieved in the fixed-bed reactor (10%) employing an Fe-oxide catalyst supported on Al2O3 (Fe-oxide@Al2O3) in both reactors. Use of a double-layered Cu-Al hydroxide (Cu-Al LDHs) catalyst in the suspension reactor further enhanced the performance with nearly 90 % OA removal observed. Given the superior performance of the suspension reactor, we investigated the impact of operating conditions (catalyst dosage, hydraulic retention time and ozone dosage) employing Cu-Al LDHs as the catalyst. We also developed a mathematical kinetic model to describe the performance of the suspension reactor and, through use of the kinetic model, showed that O3(g) interphase transfer rate was the rate-limiting step in OA removal. Thus, improvement in ozone gas diffuser design is required to improve the performance of the suspension reactor. Overall, the present study demonstrated that suspension reactors were more effective than fixed-bed reactors for oxidation of surface-active organic compounds such as OA due to the higher ozone interphase mass transfer rate and effective utilization of the catalyst surface area that can be achieved. As such, further research on suspension reactor design and development of catalysts suitable for use in suspension reactors should facilitate large-scale application of catalytic ozonation processes by the wastewater treatment industry.

Catalytic wet oxidation system of bubbleless aeration

Treatment of Condensate Wastewater in Manned Spacecraft Using a Catalytic Reactor of Membrane Aeration

Enhanced H2O2 Utilization Efficiency in Fenton-like System for Degradation of Emerging Contaminants: Oxygen Vacancy-Mediated Activation of O2.

Removal of Dilute VOCs in Air by Post-Plasma Catalysis over Ag-based Composite Oxide Catalysts

Energy Optimization of Wet Air Oxidation Reactors with Sub-Millimeter Bubble Intensification

Catalytic Ozonation of Biologically Treated Leachate from Municipal Solid Waste in a Microbubble Reactor

A thorough observation of an ozonation catalyst under long-term practical operation: Deactivation mechanism and regeneration

Ozonation degradation of wastewater using rotational hydrodynamic cavitation reactor with a conical rotor

Operational Conditions Of A Membrane Filtration Reactor Coupled With Photocatalytic Oxidation

Ozone Micro-Bubble Aeration Using the Ceramic Ultrafiltration Membrane with Superior Oxidation Performance for 2, 4-D Elimination

Mass Transfer and Interfacial Reaction Mechanisms in a Novel Electro-Catalytic Membrane Contactor for Wastewater Treatment by O3

Ozone micro-bubble aeration using the ceramic ultrafiltration membrane with superior oxidation performance for 2,4-D elimination

Treatment of H-acid industrial wastewater by catalytic wet oxidation

The Effect of Microbubbles on Gas-Liquid Mass Transfer Coefficient and Degradation Rate of Cod in Wastewater Treatment

UV/H 2 O 2 : an Efficient Aqueous Advanced Oxidation Process for VOCs Removal

Treatment of aircraft maintenance wastewater by coupling low-temperature evaporation with Fe–C micro-electrolysis-configured ozonation

Microbubbles intensification and mechanism of wet air oxidation process of MDEA-containing wastewater

Performance evaluation and optimization of a suspension-type reactor for use in heterogeneous catalytic ozonation

Bubble-less photocatalytic ozonation with ceramic membranes and static mixers enhances the total organic carbon removal and degradation of iodinated X-ray contrast agents

Effect of Ozone Oxidation Based on Microbubble

Study on the degradation of VOCs in a plasma-catalyst hybrid reactor