Abstract:The presence of grain boundary(GB) premelting can alter macroscopic properties of polycrystalline materials,which lead to catastrophic material failure as exemplified by hot cracking during high temperature processing of metallic alloys.Since the premelting is considered to occur in a very limited region,it is difficult to image and to measure thermodynamic properties of nanoscale width of liquid films.At the microscopic level capturing crystalline details,atomistic modeling techniques such as Monte-Carlo(MC) or molecular dynamics(MD) have been widely adopted,however, these methods can't be used to observe morphology of GB at atomic level.Phase field crystal(PFC) has the advantage of resolving the atomic scale density wave structure of a polycrystalline material, it naturally incorporates elastic and plastic deformations and multiple crystal orientations and can be used to study a host of important material processing phenomena.The GB premelting and melting were investigated by PFC method,microstructure evolution of premelting and melting under different misorientation angles were discussed and the film width of GB was quantitively compute in terms of the excess mass method.The results showed that the liquid film appears as the melting point is approached from below,and the morphologies of liquid film are related to misorientation angle.When misorientation angles are high-angle GB,the liquid film are homogeneous.For low-angle GB,the individual dislocations which are surrounded by liquids are uniform distributed in the GB,as the melting point is approached,structure transition occurs as follows:the dislocations form pairs and the original liquids are also combined a bigliquid pool.This structure transition not only appears during the period of premelting,but also occurs in the overheated stage,which presents a jump in the film width picture.Critical wetting angle is 12°computed by PFC method,it is more closer to the actual results than the value obtained from the Read-Shockley theory.

To what extent a crystal can be superheated

Melting As A Homogeneously Nucleated Process Within Crystals Undergoing Superheating

Melting Mechanisms at the Limit of Superheating

Melting Kinetics of Thermally Responsive Microgel Crystals

Thermodynamic Stability Limit of the Crystalline State from the Gibbs Perspective

Superheating thermodynamics of nanocrystals based on the interface effect

Homogeneous Melting Near The Superheat Limit Of Hard-Sphere Crystals

Thermodynamic superheating and relevant interface stability of low-dimensional metallic crystals

Superheating of nanocrystals embedded in matrix

Modelling for Size-Dependent and Dimension-Dependent Melting of Nanocrystals

Phase Field Crystal Study for the Effect of Heating Rate on the Premelting of Grain Boundary

PHASE FIELD CRYSTAL SIMULATION FOR THE PREMELTING AND MELTING OF GRAIN BOUNDARY

Superheating of Grain Boundaries Within Bulk Colloidal Crystals

Thermal structural disorder and melting transition in high-angle grain-boundary: a molecular-dynamics study

Melting and Superheating of Low-Dimensional Materials

Melting and Superheating of Ag at High Heating Rate

Imaging the Homogeneous Nucleation During the Melting of Superheated Colloidal Crystals

Liquid Nucleation of Surface-Free Crystal from Nanovoids

Crystallization of Supercooled Liquid Elements Induced by Superclusters Containing Magic Atom Numbers

Superheating of copper at high heating rates

Molecular dynamics simulation study on non-equilibrium melting of sodium crystals at high heating rates