Abstract:Bioreactor scale-up from the laboratory scale to the industrial scale has always been a pivotal step in bioprocess development. However, the transition of a bioeconomy from innovation to commercialization is often hampered by performance loss in titer, rate and yield. These are often ascribed to temporal variations of substrate and dissolved oxygen (for instance) in the environment, experienced by microorganisms at the industrial scale. Oscillations in dissolved oxygen (DO) concentration are not uncommon. Furthermore, these fluctuations can be exacerbated with poor mixing and mass transfer limitations, especially in fermentations with filamentous fungus as the microbial cell factory. In this work, the response of glucose-limited chemostat cultures of an industrial Penicillium chrysogenum strain to different dissolved oxygen levels was assessed under both DO shift-down (60% → 20%, 10% and 5%) and DO ramp-down (60% → 0% in 24 h) conditions. Collectively, the results revealed that the penicillin productivity decreased as the DO level dropped down below 20%, while the byproducts, e.g., 6-oxopiperidine-2-carboxylic acid (OPC) and 6-aminopenicillanic acid (6APA), accumulated. Following DO ramp-down, penicillin productivity under DO shift-up experiments returned to its maximum value in 60 h when the DO was reset to 60%. The result showed that a higher cytosolic redox status, indicated by NADH/NAD+, was observed in the presence of insufficient oxygen supply. Consistent with this, flux balance analysis indicated that the flux through the glyoxylate shunt was increased by a factor of 50 at a DO value of 5% compared to the reference control, favoring the maintenance of redox status. Interestingly, it was observed that, in comparison with the reference control, the penicillin productivity was reduced by 25% at a DO value of 5% under steady state conditions. Only a 14% reduction in penicillin productivity was observed as the DO level was ramped down to 0. Furthermore, intracellular levels of amino acids were less sensitive to DO levels at DO shift-down relative to DO ramp-down conditions; this difference could be caused by different timescales between turnover rates of amino acid pools (tens of seconds to minutes) and DO switches (hours to days at steady state and minutes to hours at ramp-down). In summary, this study showed that changes in oxygen availability can lead to rapid metabolite, flux and productivity responses, and dynamic DO perturbations could provide insight into understanding of metabolic responses in large-scale bioreactors.

Oxygen limitation improves glycerol production by Candida krusei in a bioreactor

Novel fermentation strategy for enhancing glycerol production by Candida krusei.

Enhancement of 5-keto-d-gluconate production by a recombinant Gluconobacter oxydans using a dissolved oxygen control strategy.

Effects of Phosphorus and Nitrogen Limitations on Continuous Production of Glycerol in a Multistage Cascade Bioreactor by Candida Krusei

Critical influence of osmotic pressure on continuous production of glycerol by an osmophilic strain of Candida krusei in a multistage cascade bioreactor

Model-Based Optimization of Temperature and Feed Control Strategies for Glycerol Production by Fed-Batch Culture of Osmophilic Yeast Candida Krusei

Improvement of Ethanol Production in Saccharomyces Cerevisiae by Hetero-Expression of Gapn and Fps1 Deletion

Synergic kinetic and physiological control to improve the efficiency of Komagataella phaffii recombinant protein production bioprocesses

A Novel Strategy To Construct Yeast Saccharomyces Cerevisiae Strains For Very High Gravity Fermentation

Glycerol Production by Candida Krusei Employing Nacl As an Osmoregulator in Batch and Continuous Fermentations

Oxygen alters redox cofactor dynamics and induces metabolic shifts in Saccharomyces cerevisiae during alcoholic fermentation

Enhancement of pyruvic acid production in Candida glabrata by engineering hypoxia-inducible factor 1

Improving ethanol yields in sugarcane molasses fermentation by engineering the high osmolarity glycerol pathway while maintaining osmotolerance in Saccharomyces cerevisiae

Understanding and harnessing the microaerobic metabolism of glycerol in Escherichia coli

Optimizing the balance between heterologous acetate- and CO2-reduction pathways in anaerobic cultures of Saccharomyces cerevisiae strains engineered for low-glycerol production

Glucose overflow metabolism and mixed-acid fermentation in aerobic large-scale fed-batch processes with Escherichia coli

Engineering of the glycerol decomposition pathway and cofactor regulation in an industrial yeast improves ethanol production

Effect of Elevated Oxygen Concentration on the Yeast Yarrowia lipolytica for the Production of γ-Decalactones in Solid State Fermentation

Changes in Oxygen Availability during Glucose-Limited Chemostat Cultivations of Penicillium chrysogenum Lead to Rapid Metabolite, Flux and Productivity Responses

Development of an industrial yeast strain for efficient production of 2,3-butanediol

Co-cultivation of Saccharomyces cerevisiae strains combines advantages of different metabolic engineering strategies for improved ethanol yield