Abstract:A series of H-MCM-22 zeolites with different Si/Al ratio (H-M22-x, x=15–90) were hydrothermally synthesized by boron incorporation to investigate the influences of acid density on the methanol to hydrocarbons (MTH) performances and deactivation behaviors. The acid density of H-M22-x zeolites is nearly proportional to their aluminum contents; the residual boron barely affects the overall acidity of H-M22-x zeolites. 27Al and 29Si MAS NMR experiments support the existence of competitive occupancy of various framework T sites among boron, aluminum and silicon during zeolite synthesizing, which leads to different distribution of Brnsted acid sites/framework aluminum among three types of pores in H-MCM-22 zeolites. Increasing the Si/Al ratio of H-M22-x zeolites, the proportion of Brnsted acid sites in supercages gradually increase while those in sinusoidal channels decreases. However, the acid density has a significantly larger impact than acid distribution on the MTH performances of H-M22-x zeolites. Increasing the acid density can accelerate the hydrogen transfer reactions in MTH and promote the formation of aromatics, ethene, and alkanes. The deactivation of H-M22-x zeolites with low acid density (x = 50-90) is mainly ascribed to those coke covering acid sites inside the micropores and partly blocking the pore mouths. Nevertheless, the deactivation of H-M22-x zeolites with high acid density (x = 15-30) is mainly caused by massive coke deposited on external surface which blocks the pore mouth of inner micropores. The coke on the external surface exhibits a lower decomposition temperature than that inside the micropores. The deactivation behaviors of H-M22-x zeolites for MTH can be divided into three stages. Firstly, rapid deactivation of supercages occurred for all the H-M22-x zeolites in spite of their different acid density, suggesting a much stronger influences of pore structure than acidity on the initial deactivation behaviors of H-M22-x zeolites. Secondly, the acid sites in sinusoidal channels of H-M22-x zeolites are highly resistant to coke formation, which dominate the MTH reaction in the second stage. Finally, with the continuous formation of coke in the surface pockets which gradually cover the acid sites and pore mouth of sinusoidal channels, complete deactivation of H-M22-x zeolites can be observed.

A convenient route to inactivate the external surfaces of zeolite HZSM-5

Effect of Hydrothermal Treatment on Suppressing Coking of Zsm-5 Zeolite During Methanol-To-Propylene Reaction

The acidity and catalytic behavior of Mg-ZSM-5 prepared via solid-state reaction

The Acidity and Catalytic Behavior of Mg-ZSM-5 Prepared Via a Solid-State Reaction

Regulating Surface Acid-Basic Balance on Nazsm-5 by Fe3+ Solution Towards Enhanced Methanol Dehydration

Acid-site control of ZSM-5 zeolites using quaternary ammonium hydroxides for shale gas dehydroaromatization

Rapid Absorption of Ethylene Oxide Exhaust by Catalytic Hydration on Acid Zeolite Catalysts

Disinfectant-Assisted Preparation of Hierarchical ZSM-5 Zeolite with Excellent Catalytic Stabilities in Propane Aromatization

The Effects of Silanation of External Acid Sites on the Structure and Catalytic Behavior of Mo/H–ZSM5

Facile synthesis of ultrafine nanosized ZSM-5 zeolite using a hydroxyl radical initiator for enhanced catalytic performance in the MTG reaction

Preparation and Characterization of Amphiphilic HZSM-5 Zeolite with Various Si/Al Ratios

Dealumination and Desilication for Al-rich HZSM-5 Zeolite Via Steam-Alkaline Treatment and Its Application in Methanol Aromatization

Methane Dehydroaromatization over Mo/HZSM-5 Catalysts in the Absence of Oxygen: Effects of Silanation in HZSM-5 Zeolite

Conversion of Methanol to Hydrocarbons over H-MCM-22 Zeolite: Deactivation Behaviours related to Acid Density and Distribution

Effect of Acid Treatment of Zeolite on Catalytic Performance of Mo/HZSM-5 for Methane Dehydroaromatization

Fast Recovery of Brønsted Acid Sites Lost During High-Temperature Calcination in HZSM-5

Improved Performance of Mesoporous HZSM-5 Designed with Selective Deactivation of External Surface Acidity in the Isomerization of Styrene Oxide

Regulating Hierarchical Structure and Acidity of HZSM-5 for Methanol to Aromatics Via Protective Desiliconization and External Surface Modification

Modification of ZSM-23 zeolite via vapor-phase transport method: reducing the length along the unidimensional channels for enhanced catalytic performances in methanol-to-hydrocarbons

Acid treatment to adjust zeolite hydrophobicity for olefin hydration reaction

Direct synthesis of HZSM-5 zeolites with enhanced catalytic performance in the methanol-to-propylene reaction