Experimental Investigation on Charging Characteristics and Penetration Efficiency of PM2.5 Emitted from Coal Combustion Enhanced by Positive Corona Pulsed ESP

Fei Xu,Zhongyang Luo,Wei Bo,Lei Zhao,Xiang Gao,Mengxiang Fang,Kefa Cen
DOI: https://doi.org/10.1016/j.elstat.2009.06.002
IF: 1.942
2009-01-01
Journal of Electrostatics
Abstract:The electrostatic precipitator (ESP) has been extensively used for collecting aerosol particles emitted from coal combustion, but its collection efficiency of PM2.5 (Particulate matter whose aerodynamic diameter is less than 2.5μm) is relatively low due to insufficient particle charging. The positive pulsed ESP is considered to enhance particle charging and improve collection efficiency. A laboratory-scale pulsed ESP with wire-plate electrode configuration was established to investigate the particle charging and penetration efficiency under controlled operating conditions of different applied impulse peak voltages, impulse frequencies, dust loadings and residence times. The results show that most particles larger than 0.2μm are negatively charged, while most particles smaller than 0.2μm are positively charged. For a given operating condition, the particle penetration efficiency curve has the highest penetration efficiency for particles with a diameter near 0.2μm, and there is always a negative correlation between the particle penetration efficiency and the average number of charges per particle. Under the same operating conditions, the particle penetration efficiency decreases with increasing impulse peak voltage and impulse frequency, but increases as the dust loading increases. The results imply that residence time of 4s is optimum for particle charging and collection. PM2.5 number reduction exceeding 90% was achieved in our pulsed ESP.
What problem does this paper attempt to address?