Abstract:To obtain a high biodiesel yield, the conditions of transesterification of vegetable oil with supercritical methanol are harsh. The reaction temperature is required between 350 and 400 °C, and the reaction pressure is required above 20 MPa. To reduce the operating temperature and pressure, many researchers adopted various methods, such as the selection of a new reactor, the addition of a co-solvent, or the usage of microwave irradiation. According to the characteristics of transesterification, a small amount of organic or inorgnic acid was added into the reaction system, and the effects of an acidic condition on transesterification was investigated in this paper. The experiment was conducted in a continuous flow tubular reactor; the temperature ranged from 270 to 350 °C; the pressure covered the range from the normal pressure to 15 MPa; the molar ratio of methanol/oil was from 20:1 to 60:1; and the acidity of acidified soybean oil was from 5 to 30 mg of KOH/g. The results showed that the higher yield of biodiesel was obtained at the conditions with the addition of acid compared to the corresponding conditions without acid and the increase of the yield was more remarkable under lower pressure and temperature correspondingly. Besides, it was found that the effect of inorgnic acid on transesterification was more obvious than that of organic acid. The yield of biodiesel could reach 91.4% when the reaction temperature, the reaction pressure, the methanol/oil molar ratio, and the acidity of acidified soybean oil were 350 °C, 15 MPa, 40:1, and 15.0 mg of KOH/g, respectively. It was also revealed that the transesterification reaction was still controlled by reaction kinetics to a great degree, although the reaction had reached the supercritical status.

Preparation and Bleaching of Rubber Seed Oil Biodiesel Catalyzed by Sulphuric Acid

Soft-template synthesis of sulfonated mesoporous carbon with high catalytic activity for biodiesel production

Preparation of rare earth modified clay-based solid acid catalysts and their application for biodiesel production from soybean oil

Optimization of PB011 Lipase-Catalyzed Synthesis of Biodiesel from Soybean Oil by Response Surface Method

Bleaching of cottonseed oil using acid activated bentonite treated by different dosage of sulfuric acid

Research on the Supercritical Extraction of Seed Oil from Rubber Tree and Its Composition Analysis

Synthesis of Biodiesel from Cottonseed Oil and Methanol Using a Carbon-Based Solid Acid Catalyst

Preparation of Biodiesel From Cottonseed Oil

Synthesis of Biodiesel Through Solid Acid Catalyst Iodine

Production and Optimization of Biodiesel in a Membrane Reactor, Using a Solid Base Catalyst

Production of Biodiesel from Nonedible Parkia biglobosa Oil under Acidic Condition

Effect of Weak Acids As a Catalyst on the Transesterification of Soybean Oil in Supercritical Methanol

Sulfonation of Natural Carbonaceous Bentonite as a Low-Cost Acidic Catalyst for Effective Transesterification of Used Sunflower Oil into Diesel; Statistical Modeling and Kinetic Properties

Process Parameters of Biodiesel Production Through Alkaline Catalyzed Transesteriflcation of Rapeseed Oil

Biodiesel Production by the Transesterification of Cottonseed Oil by Solid Acid Catalysts

Preparation of Biodiesel from Waste Oil Catalyzed with BrΦnsted Acid Ionic Liquid

Preparation of Biodiesel Catalyzed by Solid Super Base of Calcium Oxide and Its Refining Process

Optimization of esterification of fatty acid rubber seed oil for methyl ester synthesis in a plug flow reactor

Optimization of the Lipase-Catalyzed Irreversible Transesterification of Pistacia Chinensis Bunge Seed Oil for Biodiesel Production

Preparation of solid acid catalyst from glucose-starch mixture for biodiesel production

Preparation of Biodiesel Oil from Cottonseed Oil Catalyzed by' Ionic Liquids