Optimization of a Culture Medium for Bacillus Subtilis Based on Monosodium Glutamate Wastewater
LIU Li,ZENG Zhen,FANG Ping
DOI: https://doi.org/10.3785/j.issn.1008-9209.2015.08.291
2016-01-01
Abstract:Summary Concentrated monosodium glutamate wastewater (CMGW) generated from the production of monosodium glutamate is an organic wastewater with high concentration of ammonia,chemical oxygen demand, biochemical oxygen demand and SO2-4 and low pH. Discharge of CMGW has raised serious environmental problems,and potential secondary pollution existed even treated with traditional physical and chemical processes. It has already been reported that the richness of nitrogen and carbon makes the recycling of this wastewater possible in the way of microbial fermentation as medium.However,the differences of strain and fermentation purpose require that the medium contains different nutritional compositions with a certain dosage.Bacillus subtilis F-2,isolated from a commercial organic fertilizer,can inhibit the growth of 18 plant pathogenic fungi with varying degrees,especially in F.oxysoporum f.sp niweum with inhibition rate of 93%,which reveal the potential to prepare bio-organic fertilizer under biocontrol.In addition,F-2 also plays an important role in decomposition of organic waste.The study on degradation of food waste has pointed to its dominance in microbial community. Therefore,F-2 as a prospective functional bacteria in agriculture and environment,it is necessary to improve F-2 viable cell production as much as possible.Massive studies were focused on medium optimization of B.subtilis to enhance its cell density in fermentation liquor.However,the main ingredients of medium used in most of these studies were peptone,yeast extracts,beef extracts,soy or corn flour,associated with great cost and excessive consumption of resources. The purpose of this study was to investigate a cost-effective resource utilization of CMGW by increasing the density of B. subtilis F-2 viable cells in cultures. The CMGW medium which was 80-fold diluent of the wastewater,i.e.,12.5 g/L CMGW,was served as the main carbon and nitrogen sources of strain F-2.Contrast experiments of shaking cultures,orthogonal and single factor experiments were applied to find the optimal CMGW medium formula and its culturing condition. The contrast experiments showed that the D(600 nm) value of F-2 suspension and viable cell density of the CMGW medium was significantly higher than that of nutrient broth(NB) medium,and the amino acid content in the CMGW medium decreased significantly after culturing.The optimal formula identifying F-2 by the orthogonal experiment of L1 6(4 3 ×2 6) was as follows:12.5 g/L CMGW,1.0 g/L beef extracts,4.0 g/L peptone,0.5 g/L MnSO4 ·2 H 2 O,0.02 g/L H 3 BO3 ,0.1 g/L FeSO4 ·7 H 2 O and 0.5 g/L MgSO4 ·7 H 2 O.The viable cell density in the optimized CMGW medium was 2.9 and 6.3 times of the CMGW medium and NB medium,respectively. Furthermore,according to the results of single factor experiment,the proper initial pH and culturing temperature of the optimized CMGW medium were screened as pH 6.5 7.5 and 30 35 ℃. In conclusion,the CMGW medium is an ideal substitute for NB medium in the fermentation of B.subtilis F-2,providing a practicable and promising approach to reuse and recover CMGW.Moreover,the CMGW medium is superior to NB medium,and the fermentation effect is even better after the medium and culturing condition are optimized.