Effects of Temperature and Oxygen on Bottled Beer Aging during Storage

Wu Qianjun,Lin Hong,Li Mei,Chen Hualei,Yang Zhaoxia
DOI: https://doi.org/10.3321/j.issn:0253-990X.2006.04.001
2006-01-01
Abstract:Studies to investigate the effects of temperature and oxygen on flavor stability of Tsingtao during storage were described. Chemical data attributed to flavor stability was examined after storing for 6 months. A very high increase was found for 5-hydroxymethyl furfural (5-HMF) with higher storage temperature which increased a big margin from 20℃ to 38℃ by 244%, and it revealed no difference in 5-HMF content between beer with CO_2 and O_2. TBN acted the same as 5-HMF during beer aging, but it only increased by 5.3% from 20℃ to 38℃, the relative lower change showed that TBN is not as sensitive as 5-HMF to temperature increase during beer aging. The color increased with the increase in dissolved oxygen level and storage temperature, and the color of beer with O_2 stored at 38℃ increased by 3.18 EBC than control beer at 4℃. DPPH content decreased with the increase of storage temperature. The changes in the volatile fraction like diacetyl, esters and higher alcohols that may affect the aroma of Tsingtao during 6 months storage were also determined. The level of diacetyl increased continuous during 6 months aging, and the level in beer with O_2 was higher than with CO_2. After storing for 2 months, the content achieved its flavor threshold, therefore oxygen and temperature may cause “diacetyl” off-flavor in beer. Levels of ethyl acetate and isoamyl acetate decreased by 18% and 21% respectively after 6 months of storage at 38℃ compared to the control at 4℃, and decreased more in beer with O_2. Since levels of these two acetates in analyzed beer samples were close to their flavor threshold, the changes were expected to have an impact on the beer aroma. In conclusion, minimizing the dissolved oxygen content in beer and decreasing the storage temperature could improve the flavor stability of beer.
What problem does this paper attempt to address?