Abstract:Poly(L-lactic acid) (PLLA), a biodegradable polymer from plant sources, is widely employed in biomedical applications for its biocompatibility and versatile mechanical properties. However, comprehending its phase behavior in various solvents poses a challenge for broader applications. In this study, the phase behavior of the polymer was investigated in various solvent and cosolvent media and combinations at a wide range of temperatures and pressures to gain insight into the polymer properties. PLLA of varying intrinsic viscosity (IV): [0.15 dl/g, with an estimated weight average molecular weight (M w ) range of approximately: 1600 to 2400 g/mol; 1.0 dl/g (M w ): 100,000 g/mol); and 1.8 dl/g (M w ): 80,000 to 100,000 g/mol] was employed for this study. The phase behavior of the polymer across different compositions of PLLA and solvent (CH 2 F 2 , CHF 3 , CO 2 , DME, F-22) in a wide range of temperatures from 333 to 425 K and high pressure 1.55 to 172 MPa was investigated. Miscibility of PLLA in DME and F-22 is predicted to be higher with increasing in concentration than the other cosolvents. Furthermore, in the case of the supercritical solvent CHF 3 and DME the phase transition pressure curve of PLLA was observed to exhibit a lower critical solution temperature (LCST) type with a positive gradient with increasing temperature. However, lower phase transition pressure was noticed for lower molecular weight PLLA in supercritical solvent CHF 3 and DME, i.e., of the order IV 0.15 dl/g<iv (iv="" 1.0="" 1.8="" co<sub="" dl="" g)="" g.="" g 2 with increasing the concentration of co-solvent (F-22, DME) from 0 to ∼97 wt% shifted from UCST to LCST type. The LCST curve of PLLA (IV 0.15) in DME intersects with the vapor(V)-liquid(L) curve at T : 353 K and P below 5 MPa, indicating the coexistence of V+L phases.

Partitioning of drug model compounds between poly(lactic acid)s and supercritical CO2 using quartz crystal microbalance as an in situ detector

Determination of Apparent Drug Permeability Coefficients Through Chitosan-Sodium Cellulose Sulfate Polyelectrolyte Complex Films

Sub-microweighing Technique for Measurement of Partitioning of Drugs Between Supercritical Fluid and Impregnated Polymer

In Situ Polymerization of Poly(methyl Methacrylate)/clay Nanocomposites in Supercritical Carbon Dioxide

Determination of Paclitaxel Solubility in Carbon Dioxide Using Quartz Crystal Microbalance

Influence of Carbon Dioxide on the Phase Behavior of Pharmaceutical Drug‐Polymer Dispersions

Modulating Drug Release from Short Poly(ethylene Glycol) Block Initiated Poly(L-lactide) Di-block Copolymers

Solubility and diffusivity of supercritical CO2 for polycaprolactone in its molten state: Measurement and modeling using PC-SAFT and free volume theory

Dissolution of Polymer Films in Supercritical Carbon Dioxide Using A Quartz Crystal Microbalance

Impact of cosolvent concentration of ternary and binary solution for biodegradable poly(D,L-lactic acid) under supercritical solvents

Study of Lysozyme‐polymer Composite Microparticles in Supercritical CO2

Kinetic and Thermodynamic Interplay of Polymer-Mediated Liquid-Liquid Phase Separation for Poorly Water-Soluble Drugs

Preparation of Drug-Loaded Composites by Supercritical Carbon Dioxide Impregnation

Phase behavior of biodegradable poly(L-lactic acid) in supercritical solvents and cosolvents

Study of Lysozyme-Loaded Poly-L-Lactide (plla) Porous Microparticles in A Compressed Co2 Antisolvent Process

Differential Mobility Spectrometry-Tandem Mass Spectrometry with Multiple Ion Monitoring Coupled with in Source-Collision Induced Dissociation: A New Strategy for the Quantitative Analysis of Pharmaceutical Polymer Excipients in Rat Plasma

Thermal analysis of polylactic acid under high CO2 pressure applied in supercritical impregnation and foaming process design

Dissolution Behavior of the Crystalline Inclusion Complex Formed by the Drug Diflunisal and Poly(epsilon caprolactone)

Supercritical CO2 utilization for solubility measurement of Tramadol hydrochloride drug: Assessment of cubic and non-cubic EoSs

A Different Diffusion Mechanism for Drug Molecules in Amorphous Polymers

Effect of CO2 on the Crystallization of Poly(Lactic Acid) Homo-Crystallites via Influencing Crystal Structure of Stereocomplex Crystallites