Abstract:All industrially available zeolites are obtained from hydrogel systems. Unfortunately the level of understanding of the events preceding zeolite crystallization is far from satisfactory. In this respect, revealing the nature of the processes taking place in the precursor gel is of paramount importance to understanding zeolite nucleation. The investigation of the gel structure, however, is a difficult task due to the complexity of the object in terms of both composition and topology. Therefore, a combination of hyperpolarized (HP) (129)Xe NMR-N(2) adsorption-high-resolution transmission electron microscopy-energy-dispersive spectrometry methods complemented by X-ray diffraction, infrared spectroscopy, scanning electron microscopy, and chemical analyses has been employed to study the changes in composition and structure of sodium hydroxide rich aluminosilicate gel yielding zeolite A. The role of each component in the system and the entire sequence of events during the induction, nucleation, and crystallization stages have been revealed. The high concentration of sodium hydroxide in the studied system has been found to control the size and structure of the gel particles in the beginning stage. During the initial polymerization of aluminosilicate species a significant part of the sodium hydroxide is expelled from the gel into the solution, which restricts extensive polymerization and leads to formation of small aluminosilicate particles with open pore structure. The induction period that follows is marked by incorporation of Na back in the bulk gel. The combined action of the Na ion as a structure-directing agent and the hydroxyl group as a mobilizer results in partial depolymerization of the gel and formation of voids with mesopore sizes. The nucleation maximum coincides temporally with development of pores with sizes in the range of 2-5 nm. The amorphous gel undergoes into crystalline zeolite only after these pores have disappeared and the chemistry of the gel has evolved to reach the stoichiometric zeolite composition. It was established unambiguously by high-resolution transmission electron microscopy and HP (129)Xe NMR that the nucleation of zeolite occurs in the solid part of the system and the succeeding crystallization commences only after the nuclei are released into the liquid, which is consistent with the autocatalytic mechanism. Also this investigation has demonstrated the unrivaled sensitivity of HP (129)Xe NMR that is capable of identifying presence of small amounts of crystalline zeolite material in amorphous medium with detection limit extending below 1 wt %.

Synthesis of NaA zeolite from kaolin and its crystallization mechanism

Synthesis of Ultra-Fine NaA Zeolite by Low-Temperature Hydrothermal Treatment

Mechanism on Solvent-Free Crystallization of NaA Zeolite

Hydrothermal Synthesis of Zeolite A from K-feldspar and Its Crystallization Mechanism

Hydrothermal/Alkali Fusion Synthesis of Zeolite NaA and NaX from Pyrophyllite Mineral Clay

Study on the Mechanism of Rapid Synthesis of Small Grain NaX Type Molecular Sieve with Calcined Kaolin

Uv-Raman and Nmr Spectroscopic Studies on the Crystallization of Zeolite A and A New Synthetic Route

Synthesis of NaY zeolite molecular sieves from calcined diatomite

Alkli-activated Mechanisms of Kaolinite and Hydrothermal Synthesis of 4A Zeolite

Crystallization Process of Zeolite ZSM-5 and Zeolite ZSM-35 in a Special Autoclave

Preparation of Zeolite NaA Membranes on Macroporous Alumina Supports by Secondary Growth of Gel Layers

Controlling Crystal Transformation Between Zeolite Zsm-5 and Mordenite Without Organic Structure-Directing Agent

Synthesis zeolites in water vapour phase and their properties

Control of crystallization rate and morphology of zeolite silicalite-1 in solvent-free synthesis

Investigation of the Physicochemical Changes Preceding Zeolite Nucleation in a Sodium-Rich Aluminosilicate Gel.

Synthesis of Analcime Crystals and Simultaneous Potassium Extraction from Natrolite Syenite

Preparation of high-performance zeolite NaA membranes in clear solution by adding SiO2 into Al2O3 hollow-fiber precursor

Synthesis and characterization of zeolites NaA and NaX from coal gangue

Synthesis of high silica MOR zeolite in amine-free and fluoride-free ether-containing reactant system

Convenient Hydrothermal Synthesis of Zeolite a from Potassium-Extracted Residue of Potassium Feldspar

Simple and rapid synthesis of zeolite W from K‐feldspar via the improved hydrothermal method