Abstract:The Ti/CNT/Cu5‐Pd5, which has high denitrification ability and N2 selectivity, was prepared by adjusting the ratio of copper to palladium metal, and used as cathode in biochar substrate biofilm reactor effectively improved the removal of nitrate nitrogen in simulated groundwater with a low C/N ratio. To enhance the removal of nitrate nitrogen (NO3−‐N) in groundwater with a low C/N ratio, electrocatalytic reduction of NO3−‐N has received extensive attention since its electrons can be directly produced in situ while simultaneously providing a clean electronic donor of hydrogen for denitrifying bacteria. In this study, Ti/CNT/CuPd bimetallic catalytic electrodes with different copper‐palladium (CuPd) ratios were prepared by electrodeposition onto carbon nanotube (CNT) using titanium (Ti) plates. The results showed that the NO3−‐N conversion rate by Ti/CNT/Cu5‐Pd5 electrode was the highest (53.60%) compared with other CuPd electrode ratios because of the combined role of the copper's high NO3−‐N catalytic activity and the palladium's high N2 selectivity. A new type of electrode biofilm reactor (EBR) with Ti/CNT/Cu5‐Pd5 cathode, biochar substrate was constructed to explore the removal ability of NO3−‐N in simulated low C/N groundwater. When the influent NO3−‐N concentration was 30 mg/L, under the condition of a 30 mA electronic current and hydraulic retention time (HRT) of 12 h, the removal rate of NO3−‐N could reach as high as 78.1 ± 1.2%, and the N2 conversion rate was 99.7%. The horizontal distribution of microbial communities in EBR showed that the denitrification capacity was significantly improved through the electrochemical catalytic reduction of the Ti/CNT/Cu5‐Pd5 cathode and the supply of the hydrogen electron donor to autotrophic denitrogenerating microbes such as Anaerobacillus, Thauera, and Hydrophaga. This study provides a new bimetallic catalytic cathode to enhance the removal of NO3−‐N in groundwater with a low C/N ratio. Practitioner Points The Cu5Pd5/CNTs/Ti electrode is beneficial to the adsorption and reduction of NO3−‐N to N2. The production of hydrogen electron donors by cathode promoted nitrogen degradation. Activated electrodes together with denitrifying microorganisms contributed to the improved N removal rate.

Effect of Normal Ions on Catalytic Nitrate Reduction in Groundwater

Denitrification of nitrate in groundwater mediated by chemical catalytic action

[Chemical Denitrification of Nitrate from Groundwater].

Reduction of Nitrate from Groundwater: Powder Catalysts and Catalytic Membrane

Catalytic Reduction of Nitrate in Water over Pd-Cu/γ-Al2O3 Catalyst

Influence of operating conditions on electrochemical reduction of nitrate in groundwater

Assessment of Calcium Nitrate Addition on the AVS Removal, Phosphorus Locking, and Pb Release in Sediment

Nitrate Reduction by Chelating Resin‐supported Fe and Fe/Ni Nanoparticles: Comparison of Reactivity and Effect of Co‐existing Inorganic Anion

Effects of Ionic Interferents on Electrocatalytic Nitrate Reduction: Mechanistic Insight.

In situ evolution of electrocatalysts for enhanced electrochemical nitrate reduction under realistic conditions

Element-dependent effects of alkali cations on nitrate reduction to ammonia

Enhanced electroreduction of low-concentration nitrate using a Cu-Pd bimetallic cathode system: Performance evaluation, mechanism analysis, and potential applications

Highly selective electrocatalytic reduction of nitrate to nitrogen in a chloride ion-free system by promoting kinetic mass transfer of intermediate products in a novel Pd-Cu adsorption confined cathode

Denitrification Enhancement by Electro-Sorption/reduction Using a Layered Metal Oxide Electrode Loaded with Pd-Cu Nanoparticles

Performance and microbial response to nitrate nitrogen removal from simulated groundwater by electrode biofilm reactor with Ti/CNT/Cu5‐Pd5 catalytic cathode

Effect of Cu-Pd-TiO2 Polymetallic Nanoelectrode to Remove NO3——N in Groundwater Under Different Conditions

Hydrogen‐based Tubular Catalytic Membrane for Removing Nitrate from Groundwater

Recent advances in electrochemical nitrate removal technology in water

Groundwater Remediation By Three-Dimensional Electrode Biofilm Reactor

Research on catalytic denitrification by zero-valent iron (Fe0) and Pd-Ag catalyst

Experiment on removal of nitrate from water by electrolysis with two-dimensional electrode