Abstract:The research focuses on optimizing vegetable oil production processes for human consumption, emphasizing green and efficient extraction methods using renewable solvents with minimal toxic residues. Pressurized liquid extraction (PLE), especially with ethanol, is studied for its efficiency and low solvent usage in intermittent processes. By evaluating extraction parameters and kinetics, the study aims to determine optimal conditions for higher extraction rates and yields, providing insights into production costs and other factors. Specifically, the research examines the behavior of extraction kinetics for vegetable oils like rice bran, sunflower seeds, and rolled soybeans. It also seeks to determine mass diffusivity in semi-continuous processes and to model PLE in intermittent processes using Fick's Law and Mathematica Wolfram Software v11.2. The effective diffusivity (Deff) for rice bran oil in pressurized ethanol varied between 13.09 and 15.70 × 10−12 m2/s, and the Deff value of sunflower seed oil was between 8.10 and 12.60 × 10−12 m2/s. For rolled soybean oil, the Deff value ranged from 17.25 to 31.29 × 10−12 m2/s. The mass diffusivity values of vegetable oils in pressurized ethanol remained within the same order of magnitude. The mass diffusivity for PLE in an intermittent process presented values of 5.97 × 10−12 m2/s for rice bran oil with 3 extraction cycles. The Deff value for sunflower seed oil in pressurized ethanol was 1.38 × 10−12 m2/s, with 4 cycles, and for rolled soybeans, the Deff value was 1.77 × 10−12 m2/s in 3 cycles. The Deff value found in the intermittent extraction process was lower than that in the semi-continuous process. The total solvent renewal in the semi-continuous extraction process significantly impacted the diffusivity values for all extracted oils, as this process utilizes much more solvent compared to the intermittent process for all matrices studied. Various factors, including geometry, average particle diameter, extraction temperature, and rinse solvent volume, can affect the differences in curve behavior between the semi-continuous and intermittent processes. Despite these factors, the intermittent process is considered more viable for implementation due to its favorable economic and environmental characteristics, primarily because it requires a much smaller amount of solvent.

Comparison of Hydrolysis Kinetics of Different Vegetable Oils in Near-Critical Water

Kinetics of Hydrolysis of Ethylene-vinyl Acetate Copolymer in Near-critical Water

Study on Enzyme-Assisted Aqueous Extraction of Oil from Soybean

Development and validation of a gas chromatography-mass spectrometry method for determination of sterol oxidation products in edible oils

Absolute kinetics of peroxidation and antioxidant protection of intact triglyceride vegetable oils

Effect of the Temperature and Molar Ratio of Water-Oil on the Enzymatic Hydrolysis Kinetics of the Soybean Oil: Experimental and Mathematical Modeling

Kinetics of simultaneous change in the concentration of total lipid hydroperoxides and total conjugated dienes during peroxidation of canola, sunflower, and olive oils

Kinetic Parameters of the Thermal Oxidation and Degradation Reactions in Soybean Oil and Palm Olein

Mass Transfer and Reaction Kinetics of Soybean Oil Epoxidation in a Formic Acid‐autocatalyzed Reaction System

Kinetics of glycerol esterification reaction

Kinetics of a Hydrolysis Reaction in an Oil/Water Microemulsion System Near the Critical Point

Esterification of High-Acid Value Oil

EFFECT OF THE SURFACTANT ON ENZYMATIC HYDROLYSIS OF PALM OIL IN MICROEMULSION

Kinetics of Vegetable Oils (Rice Bran, Sunflower Seed, and Soybean) Extracted by Pressurized Liquid Extraction in Intermittent Process

Evaluation of Different Heating Systems for the Hydrolysis of Residual Frying Oil Catalyzed by Free and Immobilized Lipase

Thermostability and kinetics analysis of oil color, carotenoids and capsaicinoids in hotpot oil models (butter, rapeseed oil, and their blends)

Kinetic Analysis of Catalytic Slurry Oil Pyrolysis Using Thermogravimetric Analysis

Analysis of the thermal decomposition of commercial vegetable oils in air by simultaneous TG/DTA

Investigation of oxidized triglyceride monomer (oxTGM) produced in deteriorated soybean oil at frying temperatures: A kinetic study

Effect of extraction pH and post-extraction heat treatment on the composition and interfacial properties of peanut oil bodies

A comparative study of in vitro gastrointestinal digestion of three strategic edible oils