Abstract:Understanding the phase and interphase behavior at equilibrium and during the mass transfer between two adjacent fluid phases is relevant for optimizing and designing efficient separation processes. This study experimentally investigates the interfacial and transport behavior of systems comprising tri-ethylene glycol (TEG) and methane (CH 4 ) under conditions relevant to the gas dehydration process. A comprehensive review of the interfacial tension (IFT) and diffusivity of systems involving non-polar and polar compounds at elevated pressures was studied. However, a research gap exists, particularly concerning the interfacial tension of systems involving TEG, TEG + water, and different types of gases as well as the diffusivity of CH 4 in TEG. To address this gap, this study presents new data on mixture densities, interfacial tension, and drop volumes of TEG and TEG + water in CH 4 and CH 4 + CO 2 mixtures at temperatures ranging from 20 to 50 °C and pressures up to 250 bar using the oscillating U-tube and pendant drop methods, respectively. Additionally, time-dependent fluid mixture densities and TEG droplet volumetric expansion, coupled with an analytical approach for the binary diffusion were applied to determine the CH 4 solubility and diffusivity in TEG. The results show that IFT and drop volume of TEG and TEG + water in CH 4 and CH 4 + CO 2 mixtures decrease with increasing pressure. The presence of water increases the IFT of TEG-CH 4 up to 5mN/m, while CO 2 reduces it by 2mN/m. Interestingly, the IFT and drop volume of TEG-CH 4 show no significant change at elevated pressures when temperatures rise from 20 to 50 °C. IFT remains relatively constant over time at moderate pressures but decreases by 3mN/m at an elevated pressure of 150 bar, suggesting methane solubilization into TEG to have a significant influence which is confirmed by TEG drop volume expansion. The diffusivity of CH 4 in TEG at 150 bar and 50 °C is determined to be in the range of 10 –10 m 2 /s, which is in agreement with the diffusivity of CH 4 in liquids of similar viscosity, i.e. according correlations may be applied as good engineering practice. To the best of our knowledge, there is no such comprehensive work on the properties of fluid mixtures relevant in gas dehydration processes published up to date.

Analysis on Computer Simulation of TEG Dehydration

Analysis of a Hybrid System of Adiabatic Absorption two-stage Liquid Desiccant and CO2 Transcritical Cycles

Analysis of a Hybrid System of Liquid Desiccant and CO2 Transcritical Cycles

Influence of Operating Conditions on the Hybrid Separation Process Used for C4 Etherified Products

Analysis Study of Available Alternatives for Mitigation of Aromatic Hydrocarbon Emissions from a Glycol Dehydration Unit

Analysis of the dehydration performance in a two-phase variable-section gas wave oscillation tube

Optimization of Thermal Performance of High Temperature Sensible Heat Thermal Energy Storage System for Direct Steam Generation: a Simulation Work

Experimental and computer simulation of a molecular distillation process for the dehydration of tetramethylammonium hydroxide solution

Simulation and optimization of humidification-dehumidification evaporation system

DESIGN OF INTEGRATED PROCESS OF DISTLLIATION AND PERVAPORATION FOR THE SEPARATION OF MTBE-C4-METHANOL MIXTURE

Modification of Analytical Solutions of Coupled Heat and Mass Transfer Processes in Liquid Desiccant Dehumidifier for Deep Dehumidification

Thermodynamic Analysis of a Freeze-Dryer Utilizing Hygroscopic Solution

Multi-objective particle swarm optimization of industrial natural gas dehydration process

High sour natural gas dehydration treatment through low temperature technique: Process simulation, modeling and optimization

Thermal Investigation and Performance Analysis of a Novel Evaporation System Based on a Humidification-Dehumidification Process

Process Simulation to Design Dehydration Systems with Separators and Inline Glycol Injection Segment

Research on the Performance and Computational Fluid Dynamics Numerical Simulation of Plate Air Gap Membrane Distillation Module

Technical and economic evaluation of triethylene glycol regeneration process using flash gas as stripping gas in a domestic natural gas dehydration unit

Joule-Thomson effect and flow behavior for energy-efficient dehydration of high-pressure natural gas in supersonic separator

Analytical Solution Of Heat And Mass Transfer In Dehumidifier/Regenerator Of Liquid Desiccant Equipment

Interfacial and mass transport phenomena in the tri-ethylene glycol-methane system at process conditions of natural gas dehydration