Abstract:Thermal insulation materials are widely used in the fields of thermal protection and the energy conservation at high temperature. Thermal conductivity is one of the most important parameters of characterizing the thermal insulation performance of thermal protection materials. Steady state method such as the guarded hot plate method is normally considered as the most accurate method to measure the thermal conductivity of thermal insulation materials, but the temperature range is limited to below 1000 K. Unsteady state method can be employed at higher temperature but the accuracy is lacking of validation. Consequently, thermal verification experiments are usually conducted by heating the front surface of thermal insulation materials to a very high temperature. However, it is difficult to obtain the temperature-dependent thermal conductivity by using the thermal insulation performance measured with a large temperature difference across the material. In this study, a sandwich structure experimental system is built to carry out the thermal insulation performance tests with a large temperature difference at both steady state and transient state. Both uniform temperature layer method and polynomial fitting method are adopted to extract the temperature-dependent thermal conductivity from the large temperature difference test at steady state. A new transient state identification method is proposed based on the niche genetic algorithm to identify the relation between thermal conductivity and temperature from the transient thermal response. The temperature-dependent thermal conductivity of four thermal protection materials are finally obtained. The identification results prove that the proposed transient identification method is reliable and robust.

Experimental performance experiment measurement of flexible multi-layer insulation quilt in non-vacuum environment at high and low temperature

An experimental setup for performance testing of multilayer insulation and preliminary inspection

Effects of Structural Parameters on the Thermal Insulation Properties of Coated Carbon Fiber Fabrics

Theoretical and Experimental Study on a Compound Insulation System for High Temperature Applications

EXPERIMENTAL STUDY ON THE FACTORS AFFECTING THE INSULATION PERFORMANCE OF FLAME-RETARDANT MULTILAYER INSULATION MATERIALS

Experimental Study on the Micro-Structure and Cryogenic Insulation Performance of the Novel Micro-Fiberglass Wool Blanket

Experimental research on insulating layer heat transfer performance of a low temperature test chamber

An Experimental Investigation of Moisture Absorption and Condensation in Fibrous Insulations under Low Temperature

Design of Temperature Testing System in Multi-Parameter Combined Environmental Test

An Effective Method to Determine Bedding System Insulation Based on Measured Data

Measurement and identification of temperature-dependent thermal conductivity for thermal insulation materials under large temperature difference

Experimental study of the influences of degraded vacuum on multilayer insulation blankets

Experimental and theoretical studies on high-temperature thermal properties of fibrous insulation

Performance of high-temperature lightweight multilayer insulations

A Theoretical analysis and experimental study of effective thermal conductivities of high temperature insulations

Experimental Research on Insulating Structure′s Heat Transfer Performance of a Temperature Simulation Test Chamber

Development of multi-functional low temperature test system and experiment study

Thermal Insulations of Multilayer Clothing Systems Measured by A Bench Scale Test in Low Level Heat Exposures

Experimental study on high- low temperature environment simulation chamber with helium gas convection and cooled by liquid nitrogen

Study on Water Absorption and Thermal Conductivity of Tunnel Insulation Materials in a Cold Region under Freeze-Thaw Conditions

Insulation Performance of Heat-Resistant Material for High-Speed Aircraft Under Thermal Environments