Preparation and Enzymatic Properties of Ferulic Acid Esterase

FANG Yuan,OU Shi-yi,ZHANG Ning

DOI: https://doi.org/10.3969/j.issn.1000-9965.2012.05.010

2012-01-01

Abstract:The use of abundant and inexpensive plant fiber resources instead of limited food raw materials has become an international research focus in the field of fermented bio-energy.It may also become an important strategy to solve the future energy problems.Feruloyl esterase could remove the hydroxyl cinnamoyl esters,and thus greatly facilitate the degradation of cell wall and obtaining of trans-ferulic acid.In the present study,feruloyl esterase was prepared by solid fermentation of wheat bran and baggasse by Aspergillus awamori.The liquid of raw enzymes was precipitated by using ammonium sulfate,and then subjected to dialysis and lyophilization to get feruloyl esterase powder.The optimum pH value and temperature for this enzyme was 6.0 and 25 ℃,respectively.Cu2+,Fe2+ and EDTA could promote its enzymatic activity,while Mg2+,Zn2+,Mn2+ displayed inhibitory effects.The optimum concentrations for Cu2+,EDTA and Fe2+ were found at 0.25 mol/L,0.20 mol/L and 0.20 mol/L,respectively.The best ratio of enzyme and substrate was 1∶ 100.The productivity of enzymatic degradation reached the highest level after 1.5 h incubation.The enzymatic activities toward four natural products,including de-starch wheat bran,bagasse,corn bran and corn cob,were also examined,and the results showed that,the highest mass concentration of ferulic acid was obtained at 72.93 mg/L in DSWB,which was higher than that of the liquid of raw enzyme.Taken together,our results indicate that the enzymatic activities of feruloyl esterase increase significantly after purification.