Abstract:High-pressure-jet (HPJ) processing of various dairy systems has been shown to disrupt fat droplets and casein micelles and cause a strong association between fat and casein proteins. The present work seeks to better describe this association between fat and casein using a model milk formulated from confectionary coating fat (3.6% wt/wt), micellar casein (3.4% wt/wt), and water (93% wt/wt), which was then pasteurized, homogenized, and then either HPJ-treated (400 MPa) or not (non-HPJ-treated, control). Upon ultracentrifugation, fat in the non-HPJ-treated model milk creamed due to its low density. In the HPJ-treated model milk, fat precipitated with protein into a thick bottom layer upon ultracentrifugation, reflecting a strong association between protein and fat. Differential scanning calorimetry (DSC) and time-domain nuclear magnetic resonance of the non-HPJ-treated model milk revealed fat in 2 physical states: (1) fat that is physically similar to the bulk fat and (2) fat that was in smaller droplets (i.e., homogenized) and crystallized at a lower temperature than the bulk fat. In contrast, DSC of HPJ-treated model milks supported the presence of fat in 3 states: (1) fat that is physically similar to the bulk fat, (2) fat in small droplets that required substantial supercooling beyond the non-HPJ-treated model milk to crystallize, and (3) fat in such small domains that it crystallizes in a less stable polymorphic form than the non-HPJ-treated model milk (or does not crystallize at all). The state of fat within the HPJ-treated model milk changed minimally with acidification, indicating that the association is not dependent on the charge on the casein. Cryogenic transmission electron microscopy (Cryo-TEM) of the non-HPJ-treated model milk revealed uniform casein micelles, which likely adsorbed to the surface of fat globules post-homogenization. In contrast, Cryo-TEM of the HPJ-treated model milk revealed a porous protein aggregate that likely had dispersed fat throughout. Together, these results suggest that HPJ treatment causes fat to be entrapped by casein proteins in very small domains.

Microscopic Structure Properties of Fat Particles in Meat Batters Prepared under Shearing Conditions

Effect of pigskin gelatin hydrolysate on the porcine meat quality during freezing

IMPORTANCE OF FAT EMULSIFICATION AND PROTEIN MATRIX CHARACTERISTICS IN MEAT BATTER STABILITY

Effects of the sugarcane dietary fiber and pre-emulsified sesame oil on low-fat meat batter physicochemical property, texture, and microstructure

Mechanisms of Change in Emulsifying Capacity Induced by Protein Denaturation and Aggregation in Quick-Frozen Pork Patties with Different Fat Levels and Freeze–Thaw Cycles

Effect of low-frequency alternating magnetic field on the rheological properties, water distribution and microstructure of low-salt pork batters

Effect of oil-modified crosslinked starch as a new fat replacer on gel properties, water distribution, and microstructures of pork meat batter

The Effect of Batter Characteristics on Protein-Aided Control of Fat Absorption in Deep-Fried Breaded Fish Nuggets

Effects of Ultrasound-Assisted Emulsification on the Emulsifying and Rheological Properties of Myofibrillar Protein Stabilized Pork Fat Emulsions

Characterization of high pressure jet-induced fat-protein complexation

Influence of protein and solid fat content on mechanical properties and comminution behavior of structured plant-based lipids

Microstructure and digestive behaviors of inner, middle, and outer layers of pork during heating

Comparative analysis of quality uniformity of ohmic and water bath heating treated pork batter with different fat content

Multi-layered structure and physicochemical properties of reconstituted meat-based products from minced fish by physical extrusion: Impact of extrusion strength

Effects of different lipids on the physicochemical properties and microstructure of pale, soft and exudative (PSE)-like chicken meat gel

Insight into the Effect of Microwave Treatment on Fat Loss, Fatty Acid Composition and Microstructure of Pork Subcutaneous Back Fat

Effects of freeze drying and spray drying on the microstructure and composition of milk fat globules

Optimizing gelation properties of mixed meat myofibrillar proteins: investigating the effects of different proportions of beef, pork and chicken on physicochemical, structural and gelation properties

Quality, Thermo-Rheology, and Microstructure Characteristics of Cubic Fat Substituted Pork Patties with Composite Emulsion Gel Composed of Konjac Glucomannan and Soy Protein Isolate

Rheology and microstructure of myofibrillar protein-olive oil composite gels: Effect of different non-meat protein as emulsifier.

Effects of moderately oxidized lard on myofibrillar protein emulsion gels: Gel-forming properties, water distribution, and digestibility