Abstract:Mixed printing and dyeing wastewater (MPDW) is characterized by a low-strength chemical oxygen demand (COD; average of around 1,000 mg/L), a high fraction of recalcitrant components, a low COD/SO42- ratio (approximately 1.0), and a high pH (about 8-10 without adjustment). In this study, a biological system that combined a hybrid anaerobic baffled reactor (HABR) and a cross flow aerobic sludge reactor (CFASR) was successfully used to treat MPDW that was discharged from an industrial zone. The HABR-CFASR system was fed with real MPDW. In the start-up stage, the system had low organic loading rates of 0.66 and 0.45 kg COD/(m(3)center dot d) for the HABR and CFASR, respectively. These increased to 2.03 and 1.00 kgCOD/(m(3)center dot d), respectively, in the steady stage. The pH of the HABR influent was reduced by adding H2SO4 at a decreased dosage over the course of the experiment. Most of the final effluent from the combined treatment process was stable below 100 mg-COD/L and 20 mg-BOD/L after 12 h-HRT in the HABR followed by 20 h in the CFASR. The sulfate removal rate reached 17.59%, and the COD/SO42- ratio varied slightly around 1.0, regardless of the Ns (sulfate loading rate), which varied between 1.5 and 2.5 kgSO(4)(2-) /(m(3)center dot d). A GC/MS analysis demonstrated that the amount and types of organic compounds declined significantly after the HABR treatment.

BIOCHEMICAL TREATMENT OF CHEMICAL FIBER WASTWATER BY AN AIRLIFT TYPE CIRCULATING REACTOR

Experimental study on the domestic wastewater treatment by a high flux submerged anaerobic fabric bioreactor

Treatment of Fiberglass Wastewater

Pilot study on textile wastewater treatment by anaerobic filter reactor

Treatment and Reuse of Chemical Fiber Wastewater with High Concentration

Treatment of Wastewater from Washing and Bleaching Plants by Using Biochemical Technique and Flocculation

Study on Treatment of Chlorine Bleaching Effluent by Fluidized Bed Bioreactor-Coagulation Technology

Study on refinery wastewater biodegradation in airlift inner-loop three-phase fluidized bed bioreactor

Study on the Treatment of Chlorine Bleaching Effluent With Inner Loop Three Phase Fluidized Bed Bioreactor

Treatment to Deinking Effluent with Biological Reactor by White Rot Fungus

Comparison of biological reactors for treating odorous gas from chemical fiber wastewater treatment plant

APPLIED RESEARCH ON HOSPITAL SEWAGE TREATMENT BY PRESSURIZED AERATION BIO-REACTOR COMBINATION WITH FLOLATION

Research of Composite Membrane Bio-Reactor in Chemcial Synthetic Pharmaceutical Waste Water Treatment

Performance of a Novel HABR–CFASR System for the Biological Treatment of Mixed Printing and Dyeing Wastewater (MPDW)

Study on Performance Characteristics of Carbon Membrane-aerated Biofilm Reactor Treating Municipal Wastewater

THE ADVANCED TREATMENT OF FIBERGLASS WASTEWATER BY MEMBRANE BIOREACTOR

The Performance of A Three Phase Fluidized Bed Biofilm Reactor in Treatment of Sugar Factory Wastewater

Biodegradation Performance of an Inner-Loop Three-Phase Fluidized-Bed Bioreactor to Treat Petrochemical Wastewater

FEASIBLE STUDIES ON ACYLIC FIBER WASTEWATER TREATMENT BY A NOVEL PHOTOELECTROCATALYTIC REACTOR

Application of BF biological filler to the treatment of comprehensive chemical wastewater

Continuous Treatment of Biologically Treated Textile Effluent Using a Multi-Cell Electrochemical Reactor