Abstract:This work evaluates the catalytic activity of gel-type and macroreticular sulfonic styrene-divinylbenzene ion-exchange resins (IERs) incorporating metallic Pd or Cu nanoparticles for the synthesis of methyl isobutyl ketone (MIBK) from acetone following a one-pot synthesis approach. The effects of reaction time, temperature, and metal loading on the catalytic activity are studied, along with reusability (batch) and stability (fixed-bed) tests, highlighting the industrial potential of the most active catalyst prepared consisting of Pd-embedded particles within a strongly acidic gel-type IER support. Pd-based catalysts are more active than Cu ones, reaching 100% selectivity to MIBK and yields to MIBK of 36%, similar to the commercial benchmark also tested for comparison, i.e. AmberlystTMCH28. The highest yield to MIBK (54%) is obtained at 120 °C, 30 bar of H 2 , 300 rpm, a catalyst load of 5 wt% and a Pd loading of 1 wt% after 24 h, with margin to improvement since the catalytic activity is found to increase with temperature up to 130 °C without detectable by-products formation. The extensive characterization by several techniques (ICP-MS, SEM–EDS, N 2 physisorption, ISEC, TEM/HRTEM, and XRD) enabled to draw crucial conclusions to understand the role of IER morphology and metal used on the catalytic activity. Sintering of both Pd and Cu nanoparticles depends on the structural type of the resin support, being magnified for macroreticular resins due to an enhanced propensity towards particle coalescence in comparison to gel-type supports. The different extent of leaching observed for the Pd- or Cu- containing IERs is explained on a basis of the behavior of the corresponding metallic nanoparticles within the resins structure. The active metallic Pd or Cu phases have been identified by HRTEM, confirming the presence of metal oxide species.

Study on Macro-kinetics of Preparation of Tethyl Isobutyl Ketone Via Dehydrogenation of Methyl Isobutyl Carbinol

Producing methy1 isobuty1 ketone by dehydrogenation of methyl isobuty1 carbinol

Kinetic Investigation Of The Pyrolysis Of Isobutyric Anhydride And Isobutyric Acid

Catalytic Dehydration of 2,3-Butanediol over P/Hzsm-5: Effect of Catalyst, Reaction Temperature and Reactant Configuration on Rearrangement Products

Catalytic Hydrogenation Performance of Methyl Isobutyl Ketone Over Ni/γ-Al2O3 Catalysts

Catalytic Hydrogenation Performance of Methyl Isobutyl Ketone over Ni/gamma-Al2O3 Catalysts

Practical Preparation of Methyl Isobutyl Ketone by Stepwise Isopropylation Reaction of Acetone

Mechanism and Kinetics of Selective Aerobic Oxidation of n -Butane to Methyl Ethyl Ketone Catalyzed by Cu(HPTB)/NHPI

Vapor-phase Dehydrogenation of 3-Methyl-2-butanol over Silica-supported Cu Catalyst Prepared by Mannitol-assisted Impregnation

Investigation on Preparation of Methyl Isobutyl Ketone Through the Reduction by Isopropanol

Microkinetic analysis of isopropanol dehydrogenation over Cu/SiO2 catalyst

Process research on the catalytic hydrogenation of methyl acetate to ethanol

High-temperature Oxidation of Methyl Isopropyl Ketone: A Shock Tube Experiment and a Kinetic Model

Study on Macro-Kinetics of One-Step DME Synthesis from Synthesis Gas

Kinetic Study of Complete Liquid-Phase Catalyst for Dimethyl Ether Synthesis

One-Pot Liquid-Phase Synthesis of Methyl Isobutyl Ketone Over Bifunctional Ion-Exchange Resins: Unravelling the Role of Resins Structure and Active Pd or Cu Phases on Sintering, Leaching and Catalytic Activity

Application of fumed silica supported copper catalysts in the dehydrogenation of sec-butanol to methyl ethyl ketone

Towards High-Level Theoretical Studies of Large Biodiesel Molecules: an ONIOM/RRKM/Master-equation Approach to the Isomerization and Dissociation Kinetics of Methyl Decanoate Radicals

Study on the catalytic performance of supported skeletal nickel catalyst for hydrogenation of MIBK

Dehydrogenation of Methyl-Cyclohexane under Multiphase Reaction Conditions

Application of Cu/SiO2 Catalysts Prepared by Different Methods in Dehydrogenation Reaction of Secondary Butyl Alcohol