Abstract:This study primarily addresses the development of dynamic, selective and economical metal–acid (bifunctional) catalysts for one-pot menthol production by citral hydrogenation. Specifically, various metals such as Pd, Pt, Ni, Cs and Sn were doped over alumina support. Additionally, bifunctional composite catalysts were also prepared with the impregnation of heteropoly acids and Pd precursors over alumina support. Analytical techniques (e.g., BET, PXRD, FT-IR, pyridine adsorption and amine titration methods) were applied for characterization of the most efficient and selective catalysts (e.g., Al2O3 and PTA-Cat-I). Similarly, most of the essential operational variables (e.g., loading rate of metal precursor, type of heteropoly acid, temperature, gas pressure and reaction time) were examined during this study. The experimental data shows that the bifunctional catalyst (PTA-Cat-I) produced 45% menthol at full citral substrate conversion (r = 0.038 mmoles.min−1) in liquid-phase citral hydrogenation (at optimized operating conditions: 70 °C, 0.5 MPa and 8 h). However, the heteropoly acid-supported bifunctional catalysts (e.g., PTA-Cat-I, PMA-Cat-I, SMA-Cat-I and STA-Cat-I) resulted in cracking and the dehydration of isopulegol/menthol by the generation of side products (e.g., 4-isopropyl-1-methyl, cyclohex-1-ane/ene); therefore, menthol yield was extensively diminished. On the other hand, non-acidic catalysts (e.g., Cat-I, Cat-II, Cat-III, Cat-IV and Cat-V) readily promoted hydrogenation reactions. The optimum menthol yield occurred due to the presence of strong Lewis and weak Bronsted acid sites. Mass transfer and reaction rate were substantially diminished due to acidity strength, heteropoly acid type and blockage of pores by the applied bifunctional catalysts.

Selective hydrogenation of citral synthesis menthols over Ni-Cu/SiO_2 catalysts in ionic liquids

Synthesis of menthols via selective hydrogenation of citronellal catalyzed by Cu/ZrO2-SiO2 in ionic liquid

Preparation of Ni/SiO<sub>2</sub> catalyst in ionic liquids for hydrogenation

Preparation of Ni/SiO 2 catalyst in ionic liquids for hydrogenation

Highly Efficient Selective Hydrogenation of Cinnamaldehyde to Cinnamyl Alcohol over CoRe/TiO2 Catalyst.

Selectivity of Gold Catalysts for Selective Hydrogenation of Cinnamaldehyde

Continuous synthesis of menthol from citronellal and citral over Ni-beta-zeolite-sepiolite composite catalyst

Amine-Functionalized Hydrophobic Cross-Linked Polymer-Supported Palladium Nanoparticles: an Efficient Catalyst for the Selective Hydrogenation of Citral to Citronellal

Room‐Temperature Hydrogenation of Citral Catalyzed by Palladium–Silver Nanocrystals Supported on SnO2

One-Pot Synthesis of Menthol from Citral and Citronellal Over Heterogeneous Catalysts

Cooperation Between the Surface Hydroxyl Groups of the Support and Organic Additives in the Highly Selective Hydrogenation of Citral

Studies on Catalytic Hydrogenation of Citral by Water-Soluble Palladium Complex

Effects of Catalyst Precursor Type and Preparation Conditions, and Solvent Type on Activity and Selectivity of Pt/SiO2 Catalyst in Citral Hydrogenation

One pot menthol synthesis via hydrogenations of citral and citronellal over montmorillonite-supported Pd/Ni-heteropoly acid bifunctional catalysts

Selective Hydrogenation of Citral to 3,7-Dimethyloctanal over Activated Carbon Supported Nano-Palladium under Atmospheric Pressure

Catalytic Hydrogenation of Aromatic Nitro Compounds by Functionalized Ionic Liquids-Stabilized Nickel Nanoparticles in Aqueous Phase: the Influence of Anions

Selective hydrogenation of citral over a novel platinum/MWNTs nanocomposites

Selective Hydrogenation of Crotonaldehyde over Ir/TiO2 Catalysts: Unraveling the Metal-Support Interface Related Reaction Mechanism

Design of Nickel Supported Hierarchical ZSM-5/USY Zeolite Bifunctional Catalysts for One-Pot Menthol Synthesis via Liquid-Phase Citral Hydrogenation

Selective hydrogenation of citral toward unsaturated alcohols on PdSn catalysts supported on mesoporous silica

Design of γ-Alumina-Supported Phosphotungstic Acid-Palladium Bifunctional Catalyst for Catalytic Liquid-Phase Citral Hydrogenation