Abstract:The effect of homogenization alone or in combination with high-temperature, short-time (HTST) pasteurization or UHT processing on the whey fraction of milk was investigated using highly sensitive spectroscopic techniques. In pilot plant trials, 1-L quantities of whole milk were homogenized in a 2-stage homogenizer at 35°C (6.9 MPa/10.3 MPa) and, along with skim milk, were subjected to HTST pasteurization (72°C for 15 s) or UHT processing (135°C for 2 s). Other whole milk samples were processed using homogenization followed by either HTST pasteurization or UHT processing. The processed skim and whole milk samples were centrifuged further to remove fat and then acidified to pH 4.6 to isolate the corresponding whey fractions, and centrifuged again. The whey fractions were then purified using dialysis and investigated using the circular dichroism, Fourier transform infrared, and Trp intrinsic fluorescence spectroscopic techniques. Results demonstrated that homogenization combined with UHT processing of milk caused not only changes in protein composition but also significant secondary structural loss, particularly in the amounts of apparent antiparallel β-sheet and α-helix, as well as diminished tertiary structural contact. In both cases of homogenization alone and followed by HTST treatments, neither caused appreciable chemical changes, nor remarkable secondary structural reduction. But disruption was evident in the tertiary structural environment of the whey proteins due to homogenization of whole milk as shown by both the near-UV circular dichroism and Trp intrinsic fluorescence. In-depth structural stability analyses revealed that even though processing of milk imposed little impairment on the secondary structural stability, the tertiary structural stability of whey protein was altered significantly. The following order was derived based on these studies: raw whole>HTST, homogenized, homogenized and pasteurized>skimmed and pasteurized, and skimmed UHT>homogenized UHT. The methodology demonstrated in this study can be used to gain insight into the behavior of milk proteins when processed and provides a new empirical and comparative approach for analyzing and assessing the effect of processing schemes on the nutrition and quality of milk and dairy product without the need for extended separation and purification, which can be both time-consuming and disruptive to protein structures.

Research on the effect of temperature and homogenization pressure on measuring protein in milk

Effects of homogenisation pressures on physicochemical changes in different layers of ultra-high temperature whole milk during storage

Characterization of Metastable High Pressure Phase Transition Positions and Its Influence on the Behavior of Microbial Destruction

STUDY ON INFLUENCE OF HEAT TREATMENT ON DAIRY NUTRITION COMPONENTS AND DETECTION OF THE DEGREE OF HEAT TREATMENT

Study on comparison of the technology of protein content determination in dairy among China-US-AUS standards

Influence of temperature, time and pretreatment media on protein content of milk collected on filter paper disks

Effect of Milk Dilution Ratio on Measurement of Concentration of Protein

Thermal and Storage Properties of Milk Fat Globules Treated with Different Homogenisation Pressures

Effect Of Homogenisation On Detection Of Milk Protein Content Based On Nir Diffuse Reflectance Spectroscopy

Effect of Heating and Storage on Aggregation of Fat Globule and Protein in Milk

Modeling of the Changes in Bovine Milk Caused by Ultra-High Pressure Homogenization Using Front-Face Fluorescence Spectroscopy

Effect of Homogenization and Pasteurization Parameters on Stability of Peanut Milk

Effects of Homogenization of Different Pressures on the Creaming of UHT Milk During Storage.

Heating Treatment on Quality of Protein in Milk

Comparative Proteomics Analysis of Changes of the Milk Protein During Thermal Treatment

Effect of homogenization and pasteurization on the structure and stability of whey protein in milk.

Modeling the Effect on Skim Milk During Ultra-High Pressure Homogenization Using Front-Face Fluorescence

The Effect of Different Heat Treatments on IgG and Lactoferrin in the Milk

Differences in Physicochemical Properties and Proteomics Analysis of Spray- and Freeze-Dried Milk Powders from Bovine, Goat, and Horse Sources

Spectroscopic Evaluation of Effects of Heat Treatments on the Structures and Emulsifying Properties of Caseins

Combined effects of high-pressure treatment and storage temperature on the physicochemical properties of caprine milk