Abstract:In this work, carrier-phase direct numerical simulation (CP-DNS) is conducted for a pulverized coal flame in a temporally evolving turbulent jet with flue gas recirculation (FGR). Detailed gas phase kinetics are considered and heavy hydrocarbon molecules up to C20 are included to accurately represent tars in the volatile matter. The structure of the pulverized coal flame is analyzed with different flamelet models considering two mixing scenarios, namely the mixing of recirculated flue gases with the other fuel or oxidizer streams. In the first model approach, the mixing of recirculated flue gases with the gaseous fuels released from the coal particle is characterized with a fuel-split-based flamelet (FLT-FS) model. In the second approach, the mixing of flue gases with the transport air is described with an oxidizer-split-based flamelet (FLT-OS) model. In total, five trajectory variables are introduced in the flamelet table to represent the pulverized coal combustion states with FGR. The suitability of the flamelet models is evaluated through an a priori analysis for both the fully ignited state, as well as (more challenging) the igniting states. Comparisons show that both the FLT-FS model and the FLT-OS model perform well in predicting the thermo-chemical quantities for the fully ignited state. The FLT-OS model performs slightly better than the FLT-FS model in predicting the gas temperature and specific species mass fractions. This is due to the fact that the partial oxidization of the gaseous fuels by the hot flue gases outside the mixing layers cannot be reproduced by the FLT-FS model. While the state at the beginning of ignition can still be accurately predicted by the FLT-OS model, discrepancies can be observed for the tar species C20H10 and the intermediate species CO at a later stage when many particles ignite and the reason for this is explained. Further analysis in the flamelet solution spaces shows that the gaseous fuels are ignited on the fuel-lean side. The time evolution of the gas temperature from the beginning of ignition to the fully ignited state can be overall characterized by both flamelet models.

Numerical calculation of 2.5 MW oxy-coal swirling flame

Computational investigation of oxy-combustion of pulverized coal and biomass in a swirl burner

Numerical Investigation of Swirl-Stabilized Pulverized Coal Flames in Air and Oxy-Fuel Atmospheres by Means of Large Eddy Simulation Coupled with Tabulated Chemistry

Numerical investigation on oxy-combustion characteristics of a 200MW e tangentially fired boiler

Numerical Simulation of Oxy-coal Combustion for a Swirl Burner with EDC Model

Mathematical Modeling of Air– and Oxy–Coal Confined Swirling Flames on Two Extended Eddy-Dissipation Models

Flamelet LES of a 40 Kwth Pulverized Torrefied Biomass Furnace in Air and Oxy-Fuel Atmospheres

Flamelet LES of a Swirl-Stabilized Multi-Stream Pulverized Coal Burner in Air and Oxy-Fuel Atmospheres with Pollutant Formation

A Numerical Investigation on Flame Stability of Oxy-Coal Combustion: Effects of Blockage Ratio, Swirl Number, Recycle Ratio and Partial Pressure Ratio of Oxygen

Numerical Simulation of Temperature and Velocity Field in All-Oxygen Combustion

Numerical Investigation on Irz Dimension and Optimization of A 0.3mwt Swirl Oxy-Firing Flame in High Confinements

Flame Structure Analysis and Flamelet Modeling of Turbulent Pulverized Solid Fuel Combustion with Flue Gas Recirculation

Effects of Gas and Particle Radiation on IFRF 2.5 MW Swirling Flame under Oxy-Fuel Combustion

Numerical and Experimental Assessment of a Novel Multinozzle Burner with CO2 Diluent to Improve the Emissions from a Swirling Flame in a Combustion Chamber

Flamelet LES of Swirl-Stabilized Oxy-Fuel Flames Using Directly Coupled Multi-Step Solid Fuel Kinetics

Modeling of Pulverized Coal Combustion in Turbulent Flow with the Consideration of Intermediate Reactions of Volatile Matter

AN EXPERIMENTAL AND NUMERICAL STUDY ON SWIRLING COMBUSTION PROCESS IN A 200MW PULVERIZED COAL FIRED BOILER

Numerical Simulation of Oxy‐fuel Combustion Characteristics in a 200 MWe Coal‐fired Boiler

Numerical simulation of ultra-low calorific value gas combustion

Numerical Simulation of O2／CO2 Recycled Flue Gas Combustion in a 300 MW Boiler

Large eddy simulation of turbulent non-premixed oxy-fuel jet flames with different Reynolds numbers