Abstract:The flow condensation heat transfer coefficient of R134a inside two helical micro-fin tubes with outer diameter of 6.35 mm and helical angles of 18o and 28o respectively were experimentally studied at a high mass flux ranging from 500 to 1100 kg m−2 s−1. The condensation temperatures are 35°C, 40°C and 45°C, and the vapor qualities ranges from 0.95 to 1.00 at the inlet section and from 0.00 to 0.05 at the outlet section. Experimental results show that there are annular and intermittent flow regimes inside the tube under experimental conditions, the ratio of annular flow region to the total heat transfer region is about 70%. The liquid film flow changes from rotational flow to coexistence of rotational and horizontal flows when the vapor quality is 0.475±0.08, 0.486±0.06 and 0.521±0.05, respectively and the corresponding saturation temperature is 35°C, 40°C and 45°C. Based on the experimental data, the heat transfer coefficient increases with increasing mass flux and fin helical angle, and with decreasing saturation temperature and Reynolds number of cooling water. In addition, the heat transfer coefficient of annular flow is greater than that of intermittent flow, in other words, the heat transfer coefficient increases with increasing vapor quality. The heat transfer coefficient obtained at high mass flux was compared with the calculated data of some published correlations used at low mass flux. It was found that most correlations underestimate the experimental heat transfer coefficient inside the micro-fin tube, and these prediction deviation increases with increasing mass flux and fin helical angle. By introducing some dimensionless numbers as well as considering the flow mechanism of liquid film inside the tube, two heat transfer coefficient correlations were proposed based on the experimental data. The ratio of liquid film thickness to fin height was used to characterize whether the liquid film flow is rotational flow or coexistence of rotational and horizontal flows in the proposed correlation, which shows a better prediction accuracy with a mean deviation of less than 7.3%.

Numerical Heat Transfer Analysis of Laminar Film Condensation on a Vertical Fluted Tube

Simulation And Analysis On Heat Transfer In Laminar Oscillatory Flow In-Tube

Theoretical and Experimental Analyses of Two-Phase Flow Condensation Heat Transfer Inside the Horizontal Micro-Fin Tube

Experimental Study of Condensation Heat Transfer of R134a Inside the Micro-Fin Tubes at High Mass Flux

Numerical Analysis of Heat Transfer Characteristics of a Falling Film Type Plate-Fin Condenser/Reboiler

A Numerical Investigation of Convective Condensation in Micro-Fin Tubes of Different Geometries

Numerical analysis on flow and heat transfer of a tube bundle in a horizontal-tube falling film evaporator

An experimental study of annular film flow condensation in a micro-fin tube with high mass flux

Laminar forced convection heat and mass transfer of humid air across a vertical plate with condensation

Study on laminar film-wise condensation for vapor flow in an inclined small/mini-diameter tube

Numerical Simulation of Condensation for R410a in Horizontal Round and Flattened Minichannels

Heat transfer characteristics in vertical tube condensers: Experimental investigation and numerical validation

Laminar film condensation heat transfer on a vertical, non-isothermal, semi-infinite plate

Numerical Investigation of Air-Steam Condensation in a Vertically Enhanced Tube with Concave and Convex Surfaces

Numerical Analysis of Laminar Convective Condensation with the Presence of Noncondensable Gas Flowing Downward in a Vertical Channel

Experimental Investigation of Condensation in Micro-Fin Tubes of Different Geometries

Experimental Study and Numerical Simulation on Falling Film Thickness Outside a Horizontal Tube

Numerical Simulation of R410A Condensation in Horizontal Microfin Tubes

Numerical investigation of laminar natural convective heat transfer from a horizontal triangular cylinder to its concentric cylindrical enclosure

Approximate Equations for Film Condensation in the Presence of Non-Condensable Gases

Numerical Investigation of Convective Condensation with the Presence of Non-Condensable Gases in A Vertical Tube