Abstract:Superheated droplets vaporized in a vacuum or vapor chamber was studied using smoothed particle hydrodynamics method.The two-phase fluids of vapor and liquid with a diffused interface were modeled by Navier-Stokes-Korteweg equations,with the van der Waals equation of state.The liquid-vapor separation was processed with different initial temperature and density.Simulation was firstly validated by the proper equilibrium states with analytical data from the binodal line of Maxwell construction,as well as the droplet surface tension compared with experimental and other groups'numerical data in a good agreement.Droplet morphology,density,temperature and entropy increment were then carefully examined during the dynamic process from evaporation to boiling.Four phase transitions patterns were concluded,namely from surface evaporation,internal bubble,fragment and explosion,to flash boiling with increasing equivalent superheat degree that is defined by the non-dimensional superheat temperature over surface tension.Results showed that droplet temperature and density decreased slightly at surface evaporation when equivalent superheat degree was lower than 1/3.Above this criterion,the internal bubble could be sustained.Growth of new liquid nucleates and connected secondary liquid ring were calculated by domain growth theory.We found that droplet continuous to expand at high superheat but withdrawn at equivalent superheat degree equal to or lower than 0.52.At equivalent superheat degree higher than 1,the growth and expansion of droplet resulted in liquid fragment and explosion to many small secondary droplets.Mean mass and diameter of these droplets were found to have power-law dependency on the expansion rate.Finally,fast flash boiling occurred at equivalent superheat degree higher than 3.The vapor pressure in the chamber showed a negative linear correlation between the overpressure and the atmospheric pressure.We also found out that comparing to increase the pressure value,dense gas had better efficiency on retarding the propagation of shock wave.

Thermal Instability of Evaporating Drops on a Flat Plate and Its Effects on Evaporation Rate

Droplet Evaporation to Boiling in Van Der Waals Fluid

Molecular Dynamics Study of Binary Nanodroplet Evaporation on a Heated Homogeneous Substrate

Numerical investigation on flow instability of sessile ethanol droplets evaporating in its pure vapor at low pressure

Evaporation and explosion of liquid drops on a heated surface

The Interaction Between Droplet Evaporation and Turbulence with Interface-Resolved Direct Numerical Simulation

“Phase Diagram” of Surface Temperature Distribution of Sessile Droplets and the Effects of Evaporative Cooling

Experimental Investigation of Dynamic Evaporation Characteristics of Liquid Droplet on Heated Surface

Utilizing the Plateau-Rayleigh Instability with Heat-Driven Nano-Biosensing Systems

Thermal Non-Equilibrium Effect on Stabilities of Falling Liquid Films

Evaporation And Nucleate Boiling Of An Individual Droplet On Surfaces

Experimental studies of droplet nucleate boiling characteristics on micro-cavities surfaces with different wettability

Temperature Distribution Along The Surface Of Evaporating Droplets

Numerical Study of the Thermocapillary Instability in a Thin Liquid-Air Film

Component Effects in Binary Droplet Impact Behaviors on the Heated Plate: Comparison Study of Ethanol/Propanol and Ethanol/Water Droplets and Observation of Novel Bubble Shrinkage Phenomenon

Instability and dynamics of volatile thin films

Energy analysis of evaporating thin falling film instability in vertical tube

Boiling evaporation characteristics of sessile droplets and its transition evaporation mode

Thermocapillary flow transition in an evaporating liquid layer in a heated cylindrical cell

Instability Analysis of Evaporating Falling Film Flow in Vertical Tube

Liquid-Liquid Phase Separation Induced by Vapor Transfer in Evaporative Binary Sessile Droplets