Abstract:Nondestructive fruit quality assessment in packing houses can be carried out using near infrared (NIR) spectroscopy. However, in industrial process, some experimental conditions (e. g. temperature, fruit variety) cannot be strictly controlled and their changes would reduce the robustness of the NIR-based models. In the present paper, a total of 100 honey fruits from two super markets were used as experimental materials. Fifty honey fruits were stored at room temperature and the other fifty samples were stored at 0-4 degrees C. NIR diffuse reflectance spectra of the honey peaches were measured in the spectral range of 4 000-2 500 cm(-1) using InGaAs detector. After outlier diagnosis using leverage values and Dixon test and spectra data pretreatment with Norris derivative filter (segment length: 5, gap: 5), partial least square (PLS) regression with standard normal variate (SNV) transformation and stepwise multilinear regression (SMLR) with multiplicative scatter correction (MSV) were used to establish calibration models based on first derivative spectra. Comparing the two calibration methods of PLS and SMLR, the performances of the models developed by SMLR were found much better than that by PLS method. The best results for PLS models were: correlation coefficient of calibration (R(c)) = 0.965, root mean square errors of calibration (RMSEC) = 0.3010 Brix, correlation coefficient of cross-validation (R(cv)) = 0.812, root mean square errors of cross-validation (RMSECV) = 0.67 degrees Brix and ratio of standard deviation to root mean square errors of cross-validation (RPD) = 1.72, which were slightly worse than those for SMLR: R(c) = 0.929, RMSEC = 0.424 degrees Brix of calibration and R(cv) = 0.887, RMSECV = 0.532 degrees Brix of cross-validation and RPD = 2.16. The RPD values for SMLR models in three different spectral regions 4 290-7 817, 7 817-10 725 and 4 290-10 725 cm(-1) were: 1.97, 1.89 and 2.16, respectively. The performance of the model developed by SMLR in the 4 290-7 817 cm(-1) region was much better than that in the 7 817-10 725 cm(-1) region. The results indicated that the SMLR method could develop a good calibration model by selecting wavelengths insensitive to temperature and NIR spectra could be used for sugar content prediction of fruit samples with varied temperature when developing a global robust calibration model to cover the temperature range.

Study on Nondestructive Measurement of Sugar Content in Navel Orange by Near-infrared Transmittance Spectroscopy

Measurement of Sugar Content of Watermelon Using Near-Infrared Reflectance Spectroscopy in Comparison with Dielectric Property

Rapid Analysis of Sugar Content of Intact Orange Fruit Using Ultraviolet and Visible Transmittance Techniques

Comparison of Detection Modes in Terms of the Necessity of Visible Region (VIS) and Influence of the Peel on Soluble Solids Content (SSC) Determination of Navel Orange Using VIS–SWNIR Spectroscopy

Influence of the Peel on Predicting Soluble Solids Content of Navel Oranges Using Visible and Near-Infrared Spectroscopy

Ultraviolet-visible Transmittance Techniques for Rapid Analysis of Sugar Content and Soluble Solids Content of Fresh Navel Orange Juices

Nondestructive measurement of soluble solid content of navel orange fruit by visible–NIR spectrometric technique with PLSR and PCA-BPNN

Improving accuracy of prediction model for soluble solids content of watermelon by variable selection based on near-infrared spectroscopy

Near-Infrared Spectroscopy For Classification Of Oranges And Prediction Of The Sugar Content

Optic Fiber Sensing Technique For Evaluating Soluble Solids Content In Navel Orange Fruit Using Vis/Nir Reflectance Spectroscopy

Non-Invasive Measurements of the Internal Quality of Intact 'gannan' Navel Orange by VIS/NIR Spectroscopy

Nondestructive Sugar Content Determination of Peaches by Using Near Infrared Spectroscopy Technique

Near-infrared spectroscopy for non-destructive determination of soluble solids content of Chinese citrus

A Feasibility Study on the Non-Invasive Analysis of Bottled Compound E Jiao Oral Liquid Using Near Infrared Spectroscopy

Near-Infrared Spectroscopy for Sugar-Content Detection of Fuji Apples Using Optical Fiber

Spectral Pretreatment and Wavelength Selection for Soluble Solids Content in Gannan Navel Orange

Effect of wavelet denoising techniques on the determination of navel orange sugar content with near-infrared spectra

Application of Near-Infrared Spectroscopy with Fiber Optics for Detecting Interior Quality in Peaches

[Estimation of Soluble Solids Content of Intact Citrus Fruit by Vis/NIR Spectroscopy].

Comparison of Pls and Smlr for Nondestructive Determination of Sugar Content in Honey Peach Using Nirs

Non‐destructive Measurement of Pear Internal Quality Indices by Visible and Near‐infrared Spectrometric Techniques